2006 Ford F-150
2006 Ford F-150 TSBs (Technical Service Bulletins)
There are also 13 Ford recalls » 6 defect investigations » 38 TSBs » for the Ford F-150.
Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.
STEERING
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
SUSPENSION
- TSB #05131 -- SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION. *SC (NHTSA ID #10016794, JANUARY 01 2006)
- TSB #05919 -- FRONT TIRE WEAR ON INSIDE AND/OR OUTSIDE EDGE. *TT RAPID FEATHERING WEAR OF FRONT TIRES. *TT RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES. *TT (NHTSA ID #10017938, JUNE 07 2005)
SUSPENSION:FRONT
SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
- TSB #061916 -- SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION. *KB (NHTSA ID #10021178, no date provided)
- TSB #0765 -- REAR AXLE TUBE FRACTURE AT CENTER CARRIER. *KB (NHTSA ID #10022279, no date provided)
SERVICE BRAKES, HYDRAULIC
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
PARKING BRAKE
ENGINE AND ENGINE COOLING
- TSB #041601 -- WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT (NHTSA ID #10018745, NOVEMBER 14 2005)
- TSB #05215 -- BUCK/JERK OR SURGE - 6.0L VEHICLES BUILT BEFORE 8/22/2005. *TT (NHTSA ID #10017806, OCTOBER 31 2005)
- TSB #051713 -- COOLANT DEGAS BOTTLE OVERFLOW. *TT (NHTSA ID #10018062, OCTOBER 07 2005)
- TSB #18884 -- HARD START, NO START AND/OR OTHER SYMPTOMS CAUSED BY A HIGH PRESSURE OIL SYSTEM LEAK - SERVICE TIP. *TT (NHTSA ID #10017810, OCTOBER 01 2005)
- TSB #05102 -- MALFUNCTION INDICATOR LAMP (MIL) ON AND/OR VARIOUS DRIVEABILITY CONDITIONS - 5.4L 3-VALVE ENGINE - VEHICLES BUILT BEFORE 4/20/2005. *TT (NHTSA ID #10017935, JUNE 07 2005)
ENGINE AND ENGINE COOLING:ENGINE
- TSB #TSB-08-18-2 -- FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. * (NHTSA ID #10029205, JUNE 01 2009)
- TSB #051015 -- 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK. *TT (NHTSA ID #10018935, JANUARY 01 2005)
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO-CHARGER
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
POWER TRAIN
- TSB #0645 -- NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS. *TT (NHTSA ID #10019947, JANUARY 01 2006)
- TSB #052118 -- SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE. *TT (NHTSA ID #10017807, OCTOBER 31 2005)
POWER TRAIN:AUTOMATIC TRANSMISSION
- TSB #CSP-092908CS -- ROUSH/FORD: VEHICLES MANUFACTURED BY ROUSH WITH AN INTERCOOLED ROUSH CHARGER HAVE AN OPPORTUNITY FOR AN UPGRADE TO AN ENHANCED PCM CALIBRATION. NOT ALL F150 ROUSHCHARGED VEHICLES WILL BE AFFECTED BY THESE VARIATIONS. *PE UPDATED 1 (NHTSA ID #10026749, DECEMBER 12 2008)
- TSB #06227 -- UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT. *KB (NHTSA ID #10020676, no date provided)
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
- TSB #TSB-08-18-2 -- FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. * (NHTSA ID #10029205, JUNE 01 2009)
- TSB #CSP-092908CS -- ROUSH/FORD: VEHICLES MANUFACTURED BY ROUSH WITH AN INTERCOOLED ROUSH CHARGER HAVE AN OPPORTUNITY FOR AN UPGRADE TO AN ENHANCED PCM CALIBRATION. NOT ALL F150 ROUSHCHARGED VEHICLES WILL BE AFFECTED BY THESE VARIATIONS. *PE UPDATED 1 (NHTSA ID #10026749, DECEMBER 12 2008)
- TSB #08-5-13 -- 4.6L/5.4L--MIL P0506 AND/OR P0505--HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM. *NJ (NHTSA ID #10024828, MARCH 01 2008)
POWER TRAIN:DRIVELINE
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
ELECTRICAL SYSTEM
ELECTRICAL SYSTEM:WIRING
ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT CONTROLLER
DIGITAL INSTRUMENT PANEL
SEAT BELTS:FRONT:RETRACTOR
STRUCTURE:BODY:DOOR
TIRES
- TSB #18891 -- 20 INCH AND 22 INCH HIGH PERFORMANCE TIRES MAY EXHIBIT A VIBRATION IN STEERING WHEEL AND/OR SEAT WHILE DRIVING THE VEHICLE AFTER IT HAS BEEN PARKED FOR A FEW HOURS. *TT (NHTSA ID #10017813, OCTOBER 01 2005)
- TSB #052624 -- VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT (NHTSA ID #10018938, JANUARY 01 2005)