This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
I discovered, after my Ford Ecoboost engine light came on, that my engine needs a total replacement with only 67,000 miles on the engine. I have learned that it was a KNOWN design flaw by Ford Motor Company since 2020, the year I purchased my vehicle slightly used with 20k miles. The engine can overheat, catch fire, or seize up while driving, due to coolant leaking into the piston chambers. I was NEVER sent a recall notice, or warning of any kind from Ford Motor Company, even though this could cause an accident. I am expected to pay over $10,000 for a new engine that SHOULD have been recalled, due to their own design flaws. I see that there are multiple class actions law suits pending over this issue.
Check engine light came on for a fouled spark plug. When taken to repair shop, technician discovered that coolant was leaking into an engine cylinder. This is a known manufacturers defect that Ford Motor Company refuses to accept responsibility (see Ford Technical Service Bulletin 19-2208 - attached). Coolant is leaking at approx one gal per month. If not replaced, engine can overheat leading to further engine damage. Coolant in engine cylinder decreases driving performance with multiple misfires possibly leading to inability to avoid or causing an accident. White smoke from exhaust can hamper visualisation of following vehicles. Recall on all Ford models with Eco Boost engines is indicated with company paid repairs if coolant is leaking into engine.
Coolant intrusion in engine. My Ford escape has only 89,000 miles, it looks brand new. It-??s a manufacturer defect, the local Reno Ford is charging $9,000 to fix it. Why is not a recall from Ford? Thank you
The contact owns a 2017 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, but the vehicle was not fully diagnosed or repaired. The dealer informed the contact that the engine had failed, and that the contact would be notified what part of the engine needed to be repaired, or if the engine needed to be replaced. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 20,000.
- Hammonton, NJ, USA
Search CarComplaints.com for these popular complaint phrases...
On Sunday, 7/6 the check engine light came on. The vehicle was dropped off at a Ford dealership for review and it was determined that a coolant leak into cylinders causing internal damage to the engine. Recommendation is to replace the main engine assembly (long block) at $10,000. Which is more than what the car is worth. The car currently has 102,062 miles. This appears to be a known issue among the model year of the Escape and engine type. Currently there is no assistance in helping with the cost of repairs. We have contacted Ford and asked for assistance as we are long time Ford vehicle owners. They logged the following: CXH-05084174-H2Q6H1 and recommended that we log an issue with the NHSTA.
Started having issues with the power of the engine, white smoke from exhaust, and loss of coolant. Apparently there are multiple TSBs about this problem, and has been discovered to be an engine design failure for several models under Ford and Lincoln and it is still not a recall. This issue is known to ruin the head gasket and ultimately crack the cylinder head. If I had not spoke to my mechanic about the white smoke and power loss, he would not have recommended that I check my fluids and saw I was losing coolant untimely. Due to it leaking into the engine every time I drove my car. He also stated that he-??s seen this issue before, found multiple sources around the country that have seen the same issue and basically fixing the issue won-??t ultimately fix the problem. Because the engine design is defective, the problem will happen again. The engine would have to replaced. Which costs more than the car is worth. It-??s very dangerous to have a faulty engine design and not do a proper recall or replacement plan.
I own a 2017 Ford Escape with approximately 102,000 miles. I am the original and only owner and have had regular maintenance done on my vehicle the entire time I've owned it. After a recent 9-hour road trip, I experienced sudden engine failure with no prior warning signs. My local dealership has diagnosed the issue as coolant intrusion into the engine, which caused catastrophic engine damage and now requires a full engine replacement at a cost of $8,800. After researching the issue, I discovered this is a known and widespread problem with EcoBoost engines in 2013-2019 Ford Escapes and other Ford vehicles. Ford has issued Technical Service Bulletins regarding this, and there is at least one ongoing class action lawsuit related to engine failure caused by coolant intrusion. This problem poses serious safety concerns, especially when it causes vehicles to fail unexpectedly at highway speeds or in unsafe conditions. I am filing this report to document the issue and urge NHTSA to investigate this known defect.
[XXX] Car began to run rough as if it had bad gas and the engine would not idle smoothly. When I got into the vehicle the next day the instrument panel flashed lights and the vehicle stalled. I had it towed to the repair shop thinking it was overheating due to a bad thermostat. I was told that the engine coolant was leaking into cylinder 4 of the engine and I would have to replace the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My vehicle has been suffering coolant intrusion into the engine, specifically the cylinders, causing significant damage and leading to my vehicle overheating. After discovering the issue at my mechanic, I found out there was a recall for my specific vehicle for this issue, but my VIN was not included. Not being notified of this issue by a recall risked my vehicle overheating and potentially starting a fire which could have been hazardous to myself and any passengers.
There is an issue with the type of engine used in these vehicles where coolant leaks into the engine causing cylinder misfires. This is a known issue that has not been issued a recall. I have had a complete repair done in the past involving the complete reconstruction of the engine, however after only 21,000 miles the repair failed.
No visble coolant leaks, have to refill antifreeze resevoir weekly, missfiring #2 cylinder as result, ignition coil for that cylinder and plug work fine
This vehicle has had multiple issues with starting. But now there-??s a -??Steering Assist Fault-?? that clearly ford is aware of but has decided that manufacturing this vehicle anyway was the way to go. The vehicle won-??t start again now because of this issue. What happens is the vehicle loses its assisted steering and sometimes while driving which is extremely dangerous.
Coolant intrusion at only 56,000 miles due to defective engine design. Engine replacement is the only remedy. This has been happening to cars with as little as 20,000 miles. Ford knows about it, there is a TSB that says the repair is "replace engine." At a cost of ~$10,000. Ford can't be allowed to sell cars with defective engines that fail at low mileage saddling consumers with astronomical repair fees. These vehicles can catch fire or leave someone stranded in the middle of nowhere, as well. It's absolutely outrageous that there has not been a recall with how many vehicles have been affected. The government needs to step in and help people. I have tried to upload files, but the site won't let me.
In 2024 the vehicle was brought in for a P0012 code, rough idling, loss of power, and hesitation when accelerating. The cam phasers were the culprit which were replaced along side multiple gaskets, and the timing belt. The tensioner was not replaced at that time. One year the vehicle is performing the same way, threw a P0012 code, rough idle, and loss of power. This time the dealership found suspended metals in the oil, and discovered scoring in the chambers. They refuse to look at the cam phasers or belt to see if there is wear or damage.
Engine is being less powerful and losing coolant like crazy, looked up what issue is and these engines are known to leak coolant into the engine, in the long run ruining the engine, mine is misfiring and running awful at this point, tried to have ford do something and they acknowledged it-??s an issue but won-??t do anything without me paying thousands of dollars
The problem with my 2017 Ford Escape began in June 2021 (mileage 65652) when the engine warning light came on and there was white exhaust smoke. Our local mechanic tried various actions to determine why the engine light was on, such as performing a GDI treatment for carbon buildup, but over the summer months none of his actions were successful but each action was an incurred expense. By August 30, 2021, a new warning appeared -??High Engine Temp. Stop Safely-??. At this point our mechanic found a Technical Service Bulletin regarding the 2017 Ford Escape 2.0L EcoBoost engine coolant in cylinders and my car was towed to our local Ford dealership in Prince Frederick, MD. The Ford dealership verified our concern as follows: -??Tech Notes: Verified Concern, Check Engine Light Missfire Code Cylinder #3. Remove Plug, Coolant Fouled. Coolant Intrusion. Ford Assisting Customer on Repair. CAS-33032232-M8C9Z8. Remove and Replace Long Block Assembly. Test Drive After Repair. Concern Corrected. Approval Code MSPA102662-?? Answers to Your Questions: (1) It's a engine failure (2) Potential of sudden stops with engine failure (3) Ford Dealer inspected my engine and verified the problem and Ford corporate issued Technical Bulletins on problems with Ford Escape 2.0L Ecoboost engine (4) Yes, engine warning light and High engine temp light with instruction to stop safely06/23/2021.
Coolant intrusion into engine causing the car to over heat and break down multiple times. On going issue unable to be repaired by multiple mechanics for a year and a half. Coolant leak confirmed during diagnostic using a scope.
The contact owns a 2017 Ford Escape. The contact stated that while attempting to start the vehicle remotely, the vehicle failed to start. The contact stated that when the vehicle was started manually, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a misfire in cylinder #4. The contact was informed that the spark plugs needed to be replaced. The vehicle was repaired; however, the failure reoccurred three days later. The manufacturer was notified of the failure. The failure mileage was 69,900.
The contact owns a 2017 Ford Escape. The contact stated while driving 70 MPH, the vehicle shuddered and stalled. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was able to restart but was undrivable. The vehicle was towed to Firestone but was not repaired. The vehicle was then towed to the dealer, where it was diagnosed and determined that a cracked fuel injector had leaked fuel into cylinder #3, creating a hole in the cylinder and the engine. The dealer determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to an unknown recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 92,000.
A D V E R T I S E M E N T S
- Albuquerque , NM, USA