- August 29: GM Recalls Vehicles With Driveshafts That Break recalls | 21 days ago
- August 10: GM Recalls 2017 Chevy Silverado and GMC Sierra Trucks recalls | 40 days ago
- August 7: GM Oil Consumption Lawsuit About Vortec 5300 Engines Dismissed news | 43 days ago
- August 6: Duramax Diesel Lawsuit Claims Emissions Are Illegal news | 44 days ago
- August 4: GM Recalls Chevrolet Silverado 1500 and GMC Sierra 1500 recalls | 46 days ago
2004 GMC Savana
6 Recalls & Safety Reports
Recall List for the 2004 GMC Savana
Official recalls have been issued for the 2004 GMC Savana by the NHTSA. The complete details of all recalls are listed below, along with what they cover and the recommended solutions.
Recalls don't cost you anything to get fixed, but most are time-limited, so if your car is affected you should call your local GMC service department immediately!
If you have questions about a recall, write down your VIN & then call GMC customer service.
2004 GMC Savana FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP NHTSA Campaign #12V388000
Summary: General Motors (GM) is recalling certain model year 2003-2004 Chevrolet Express and GMC Savana vehicles, equipped with a left side cargo door, and originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Water and road contaminants may become trapped in the protective conduit that covers the fuel filler pipe and may cause the pipe to corrode.
Consequence: Significant corrosion may allow fuel to leak during refueling, and in the presence of an ignition source; there is an increased risk of fire.
Actions: GM will notify owners, and dealers will install a new fuel filler neck, free of charge. The safety recall began on October 1, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546 and GMC at 1-866-996-9463. For detailed information & supporting documents, see the official NHTSA page concerning recall #12V388000 »
2004 GMC Savana SEAT BELTS NHTSA Campaign #05V558000
Summary: On certain full-size passenger, cargo, or cutaway vans, the front and rear seat belt buckles will not latch or will not unlatch.
Consequence: In the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury.
Actions: Dealers will inspect the buckles and, if found to be inoperative, the entire buckle assembly would be replaced. For buckles found to be operative, dealer will replace only the upper buckle cover. The recall will be conducted in phases. The first phase mailing began during March 2006. Owners may contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463. For detailed information & supporting documents, see the official NHTSA page concerning recall #05V558000 »
2004 GMC Savana SERVICE BRAKES, HYDRAULIC NHTSA Campaign #05V043000
Summary: Certain trucks, sport utility vehicles, and vans equipped with Bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.
Consequence: If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. The presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.
Actions: Dealers will test the hydro-boost assembly for functional operation of the two-function valve. If the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. The recall began on March 23, 2005. Owners may contact Chevrolet at 1-800-630-2438, GMC trucks at 1-866-996-9463 and Hummer at 1-800-732-5493. For detailed information & supporting documents, see the official NHTSA page concerning recall #05V043000 »
2004 GMC Savana POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT NHTSA Campaign #04V320000
Summary: Certain vans were built with a transmission shift cable assembly that may separate. If the cable assembly separates, the transmission shift lever position and the transmission indicator may no longer correlate.
Consequence: If this were to occur, the vehicle could move in a direction not anticipated by the driver, which could result in a vehicle crash.
Actions: Dealers will inspect the transmission shift cable assembly, and if necessary, replace it. The recall began on August 19, 2004. Owners should contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V320000 »
2004 GMC Savana SEAT BELTS:FRONT:BUCKLE ASSEMBLY NHTSA Campaign #04V189000
Summary: Certain vans fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 209, "seat belt assemblies." These vehicles may have been produced with seat belt buckle assemblies containing a latch with a brittle condition that may not withstand the force requirements of the standard.
Consequence: The safety belt may not restrain the occupant as intended during a crash, which could result in injury to the occupant.
Actions: Dealers will replace the safety belt buckle. The recall beagn May 7, 2004. Owners should contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V189000 »
2004 GMC Savana SERVICE BRAKES, HYDRAULIC NHTSA Campaign #04V045000
Summary: Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of Federal Motor Vehicle Safety Standard no. 135, "passenger car brake systems." Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
Consequence: Consequently, the valve O-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
Actions: Dealers are to replace the hydro-boost relief valve. The recall began on June 18, 2004. Owners should contact Cadillac at 1-866-982-2339; Chevrolet at 1-800-630-2438; GMC at 1-866-996-9463; or Hummer at 1-866-486-6376. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V045000 »
Browse Other Savana Years
- 2016 GMC Savana
- 2015 GMC Savana
- 2014 GMC Savana
- 2013 GMC Savana
- 2012 GMC Savana
- 2011 GMC Savana
- 2010 GMC Savana
- 2009 GMC Savana
- 2008 GMC Savana
- 2007 GMC Savana
- 2006 GMC Savana
- 2005 GMC Savana
- 2004 GMC Savana
- 2003 GMC Savana