Technical Service Bulletins (TSBs) for the 2015 Macan are official communications between Porsche & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Symptom: Customers complain about disturbing noises coming from the footwell area on the driver's side while steering. Cause: The surface of the foam rubber seal in the sealing sleeves starts to wear and crumble due to high temperatures. Read More »
"THERE IS INCREASED FRICTION IN THE AIR SPRING COMPRESSOR VALVES AT TEMPERATURES BELOW ?13? F (?25? C). THIS CAN RESULT IN A SITUATION IN WHICH THE MAXIMUM CONTROL CURRENT IS NOT SUFFICIENT TO ACTUATE THE VALVES. Read More »
Technical Background Front brakes are squealing with light pedal at low speed. The noise is primarily in the 8 kHz range. Service Information Test drive the vehicle and verify the noise with an FFT plot. Read More »
Information: It is possible that a faulty wheel speed sensor can be the root cause of the multiple warnings. Check the fault memory for the following types of faults for one or more wheel speed sensors. Read More »
Information: It is possible that a faulty wheel speed sensor can be the root cause of the multiple warnings. Check the fault memory for the following types of faults for one or more wheel speed sensors. Read More »
Concerns: Belt tensioner Information: Checking belt tensioner in the event of a complaint about "leaks" before carrying out any other work. Read More »
Concerns: Belt tensioner Information: Checking belt tensioner in the event of a complaint about "leaks" before carrying out any other work. Read More »
Instructions on the manufacturers certificate for allocation of approved engine oils up until MY2020. (starting back at MY1984). An overview of the approved engine oils. Read More »
Technical information regarding a warning message - "engine control system fault" in conjunction with fault memory entries in the PDK control unit. Read More »
Technical information concerning possible leaking coolant pipes at the front of the cylinder head in certain Cayenne and Macan vehicles. The remedy is to install a coolant pipe with a toothed ring. Read More »
Repair instructions for Timing chain repair. If an oil leak is identified from the timing chain cover and it has been found that any part on the timing cover has failed, then the engine must be removed and the entire timing chain cover ... Read More »
Notice to dealers that coolants will be moved out of the special tool cabinet in the dealer service department in order to make room for new special tools. Read More »
Subject: Air-conditioning control unit (also control panel/switch console) Symptom: When starting the vehicle, an unsuitable air conditioning setting is preset in the rear air-conditioning control unit. Read More »
Information on new model designation logos which can be purchased and applied to the rear exhaust area of a vehicle, displaying the model designation on the outside of the vehicle. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Subject: Intake valves and intake ports Information: Carboned-up valves in the engine can be reworked and cleaned using cleaning equipment. If there is a complaint about knocking combustion, e.g. Read More »
PORSCHE: IN SOME CASES, ON SOME VEHICLES, THERE CAN BE AN INCORRECT DIAGNOSIS OF TANK LEAKAGE DUE TO DIRT PARTICLES IN TANK LEAKAGE DIAGNOSIS MODULE AND BE DEPOSITED ON DIAPHRAGM SEAL. MODEL 2015 MACAN S, MACAN TURBO. Read More »
Concern: An oil leak can occur close to the connection point between the intermediate housing (? Oil leak on PDK transmission -item 1-) and cover (? Oil leak on PDK transmission -item 2-) on the PDK transmission due tomanufacturing ... Read More »
Oil leak/leak on PDK transmission close to the connection point between the intermediate housing and cover. Insufficient cross-cut made at the flange and as a result, the sealant has not bonded sufficiently. Read More »
Information: In certain driving situations, the transmission only switches from 1st to 2nd gear at a significantly higher engine speed when selector-lever position "D" is engaged. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Symptom based workshop manual information - eliminating symptoms in body interior: Re-calibrating Surround View Camera Control Unit (for I-no. 8A4) Read More »
Technical information regarding a warning message - "engine control system fault" in conjunction with fault memory entries in the PDK control unit. Read More »
Instructions for how to perform a software update on the Control unit for the auxiliary alarm system in the event that the vehicle will not start. Read More »
Resubmitting at request of Mr. Bernard Hardgrave. Instructions for reworking the wire harness for the outside temperature sensor in the event that outside temperature display is implausible. Read More »
Concerns: Battery trickle charging with "Charge-o-mat"may time out within a short period of time. The trickle charging will thus end prematurely. Thismay result in a dead battery. Read More »
This bulletin replaces bulletin Group 2 #58/14 dated 12/01/2014 - Updated Gateway Coding Will allow 12v battery Trickle Charging Using "Charge o-mat" with the 12v Socket (58/14) Read More »
Due to incorrect fitting of the front hood lock cable, there is a possibility that the cable will rub against the microswitch for the hood lock. This will damage the microswitch. Read More »
Information: A Cayenne with optional equipment no. 1D6 will come with a Trailer hitch receiver and wiring up to the receiver hitch that includes a control unit to operate the trailer parking lights, turn signals and brake lights. Read More »
Concern: Coding failures of the instrument cluster. Information: Ensure the Auto Memory option is deselected prior to replacing or coding an Instrument Cluster on all Macan models. Read More »
Subject: Outside temperature display in the instrument cluster Information: Customers complain that the outside temperature value in the instrument cluster is implausible and does not change. Read More »
If the software versions are no longer compatible, it may no longer be possible for the DME control unit to communicate with the instrument cluster via the gateway control unit. Read More »
Due to incorrect fitting of the front hood lock cable, there is a possibility that the cable will rub against the microswitch for the hood lock. This will damage the microswitch. Read More »
There is increased friction in the air spring compressor valves at temperatures below ?13? F (?25? C). This can result in a situation in which the maximum control current is not sufficient to actuate the valves. Read More »
The customer observes an MIL. The technician is able to verify the MIL and notices fault code P0071 stored in the DME. PCNA is aware of this this issue. Read More »
PORSCHE: DATA RECORDS FAIL TO COMPLY TO CURRENT STANDARDS REGARDING TRANSFER GEARS WITH CONTROL UNIT AT TIME OF DELIVERY AND WOULD NEED ALL WHEEL DRIVE CONTROL UNIT REPROGRAMMED. MODEL 2014-15 MACAN S, DIESEL, TURBO. Read More »
Symptom: Symptom 1: Right headlight has interior condensation. Symptom 2: One or both headlights has/have interior condensation Remedial action 1: The breather hose 95B.941.560. Read More »
Symptom based workshop manual information - eliminating symptoms in body interior: Re-calibrating Surround View Camera Control Unit (for I-no. 8A4) Read More »
Subject: Front power windows Symptom: Unusual noises can occur when you open and close the front door window. Squeaking, rattling or noises can indicate that the door window glass is stiff. Read More »
Symptom-based workshop manual for the body exterior. drains on rear panoramic roof blocked - checking water drain hoses, cleaning, and replacing drain sleeves Read More »
Concerns: Spray nozzle for rear window washer Information: This is to inform you of a voluntary Workshop Campaign on the above-mentioned vehicles. Read More »
Concerns: Spray nozzle for rear window washer Information: This is to inform you of a voluntary Workshop Campaign on the above-mentioned vehicles. Read More »
PORSCHE: PASSENGER AIR BAG LIGHT IS ON, ONCE IGNITION SWITCH IS TURN ON, FIVE MINUTES LATER AIR BAG LIGHT SPORADICALLY GOES OUT 5 MINUTES LATER. CONTROL UNIT OF AIR BAG NEEDS REPROGRAMMING. MODEL 2014-15 MACAN. Read More »
Symptom-based workshop manual for the body exterior. drains on rear panoramic roof blocked - checking water drain hoses, cleaning, and replacing drain sleeves Read More »
Concerns: Protective film for rear door sill Information: This is to inform you of a voluntary Workshop Campaign on the above-mentioned vehicles. Read More »
RESUBMITTING AT THE REQUEST OF B HARDGRAVE. This bulletin from January 2017 contains instructions on how to eliminate noise symptoms in the Macan when opening the hood. Read More »
RESUBMITTING AT THE REQUEST OF B HARDGRAVE. This bulletin from January 2017 contains instructions on how to eliminate noise symptoms in the Macan when opening the hood. Read More »
There is a possibility that covers on front and rear doors can become loose and start to stick up due to adhesion problems. In the event of a customer complaint, all four covers on front and rear doorsmust be replaced. Read More »
Information: The upper front hood latches have a fine adjustment not mentioned in the workshop manual. A fine adjustment to change the depth of the upper latch striker may be made at the bolt shown in the photo above. Read More »
Customer Concern: Vehicle has an issue that ends up requiring a wheel alignment. Technical Concern: The VAS 6918 adapters may be confused, resulting in an improper alignment. Read More »
Information: A Cayenne with optional equipment no. 1D6 will come with a Trailer hitch receiver and wiring up to the receiver hitch that includes a control unit to operate the trailer parking lights, turn signals and brake lights. Read More »
Subject: Front camera Symptom: The customer complains that certain functions of the front camera are not available at times: Lane Change Assist not available Porsche Dynamic Light System not available Traffic sign recognition not ... Read More »
Symptom-based workshop manual for the body exterior. drains on rear panoramic roof blocked - checking water drain hoses, cleaning, and replacing drain sleeves Read More »
Service Information There was a parts supply error and incorrect parts were stocked. An order to correct this error has been initiated and the stock will be clean soon. Read More »
Symptom: Customers complain about disturbing noises coming from the footwell area on the driver's side while steering. Cause: The surface of the foam rubber seal in the sealing sleeves starts to wear and crumble due to high temperatures. Read More »
RESUBMITTING AT THE REQUEST OF B HARDGRAVE. This bulletin from January 2017 contains instructions on how to eliminate noise symptoms in the Macan when opening the hood. Read More »
This bulletin replaces bulletin Group 2 #58/14 dated 12/01/2014 - Updated Gateway Coding Will allow 12v battery Trickle Charging Using "Charge o-mat" with the 12v Socket (58/14) Read More »
Information: The customer complains that certain functions of the front camera are not available at times: * Lane Change Assist not available * Porsche Dynamic Light System not available * Traffic sign recognition not available Cause: ... Read More »
Information: The Approval and Support Management system was created to offer assistance to the dealer organization with new and complex technical issues by utilizing the Support Specialists within Porsche R&D. Read More »
The customer observes an MIL. The technician is able to verify the MIL and notices fault code P0071 stored in the DME. PCNA is aware of this this issue. Read More »
1997 to Present - Vehicle Analysis Log Types - In an effort to prode accurate information regarding the state of the vehicle at the time fof VAL creation, a "log type" drop down menu was added at the end of the VAL creation menu. Read More »
Information: The upper front hood latches have a fine adjustment not mentioned in the workshop manual. A fine adjustment to change the depth of the upper latch striker may be made at the bolt shown in the photo above. Read More »
Concerns: Belt tensioner Information: Checking belt tensioner in the event of a complaint about "leaks" before carrying out any other work. Read More »
RESUBMITTING AT THE REQUEST OF B HARDGRAVE. This bulletin from January 2017 contains instructions on how to eliminate noise symptoms in the Macan when opening the hood. Read More »
PORSCHE: DATA RECORDS FAIL TO COMPLY TO CURRENT STANDARDS REGARDING TRANSFER GEARS WITH CONTROL UNIT AT TIME OF DELIVERY AND WOULD NEED ALL WHEEL DRIVE CONTROL UNIT REPROGRAMMED. MODEL 2014-15 MACAN S, DIESEL, TURBO. Read More »
Subject: Air-conditioning control unit (also control panel/switch console) Symptom: When starting the vehicle, an unsuitable air conditioning setting is preset in the rear air-conditioning control unit. Read More »
Subject: Air-conditioning control unit (also control panel/switch console) Symptom: When starting the vehicle, an unsuitable air conditioning setting is preset in the rear air-conditioning control unit. Read More »
Symptom: No cooling performance from the air-conditioning system. Cause: The evaporator for the air-conditioning system can freeze at high outside temperatures and high humidity. Read More »
The customer observes a MIL and the HVAC controls are not functioning. Also, other Comfort CAN commodities may not function. PCNA is aware of this issue. Read More »
The customer observes a MIL and the HVAC controls are not functioning. Also, other Comfort CAN commodities may not function. PCNA is aware of this issue. Read More »
Customer Situation: The airflow from the vents may be reduced dramatically while the blower is still running during extended trips with lower fan speed settings (4 bars and below). Read More »
Concerns: Control unit for air-conditioning system Information: This is to inform you of a voluntary Workshop Campaign on the above-mentioned vehicles. Read More »
