- September 16: Ford Explorer Wheel Hub Bearing Assemblies Recalled recalls | 3 days ago
- September 15: Ford Explorer Carbon Monoxide Investigation Upgraded investigations | 4 days ago
- September 12: Ford PowerShift Dual-Clutch Transmission Settlement Questioned news | 7 days ago
- August 31: Ford Recalls F-150 and Mustang Over Deadly Airbags recalls | 19 days ago
- August 31: Ford Recalls Explorer, Taurus and Police Interceptors recalls | 19 days ago
2002 Ford Expedition
4 Recalls & Safety Reports
Recall List for the 2002 Ford Expedition
Official recalls have been issued for the 2002 Ford Expedition by the NHTSA. The complete details of all recalls are listed below, along with what they cover and the recommended solutions.
Recalls don't cost you anything to get fixed, but most are time-limited, so if your car is affected you should call your local Ford service department immediately!
If you have questions about a recall, write down your VIN & then call Ford customer service.
2002 Ford Expedition EXTERIOR LIGHTING:HEADLIGHTS NHTSA Campaign #06E067000
Summary: Certain maxzone headlight assemblies, depo brand, P/nos. 331-1129L-asn and 331-1129R-asn, sold for use as aftermarket equipment for the above listed passenger vehicles. These headlamps fail to conform to the photometric requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Consequence: Decreased lighting visibility may result in a vehicle crash.
Actions: Maxzone will notify owners and offer reimbursement for any noncompliant headlights. The recall began on July 28, 2006. Owners may contact maxzone at 909-822-3288. For detailed information & supporting documents, see the official NHTSA page concerning recall #06E067000 »
2002 Ford Expedition FUEL SYSTEM, GASOLINE NHTSA Campaign #06E056000
Summary: Certain aftermarket fuel filters sold under the purolator brand name, P/N F65277, shipped from January 16 through June 2, 2006, for use on the above listed passenger vehicles. Due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
Consequence: Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
Actions: Ufi will notify owners and replace the filters free of charge. The recall began on August 4, 2006. Owners may contact ufi filters usa at 800-230-5876. For detailed information & supporting documents, see the official NHTSA page concerning recall #06E056000 »
2002 Ford Expedition VEHICLE SPEED CONTROL NHTSA Campaign #05V388000
Summary: On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
Consequence: A fire at the switch could occur.
Actions: By letter dated September 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. Owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in February 2006. Owners who did not have their speed control deactivated are being notified to have their system remedied beginning in February 2006. Owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. Owners may contact Ford at 1-800-392-3673. (note: Also see recalls 05V017 and 06V286) For detailed information & supporting documents, see the official NHTSA page concerning recall #05V388000 »
2002 Ford Expedition STRUCTURE NHTSA Campaign #03V094000
Summary: Certain pickup truck, van, and mini van conversions equipped with Southern Comfort built running boards that contain certain courtesy lights manufactured by american technology components, Inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
Consequence: This overheating condition can cause the running board to melt or cause a fire.
Actions: Dealers will replace the wiring harness on these running boards. Owner notification began March 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Southern Comfort at 1-800-745-6096. For detailed information & supporting documents, see the official NHTSA page concerning recall #03V094000 »
Browse Other Expedition Years
- 2016 Ford Expedition
- 2015 Ford Expedition
- 2014 Ford Expedition
- 2013 Ford Expedition
- 2012 Ford Expedition
- 2011 Ford Expedition
- 2010 Ford Expedition
- 2009 Ford Expedition
- 2008 Ford Expedition
- 2007 Ford Expedition
- 2006 Ford Expedition
- 2005 Ford Expedition
- 2004 Ford Expedition
- 2003 Ford Expedition