Print this page

Recall List for the 2004 Chevrolet Express

Official recalls have been issued for the 2004 Chevrolet Express by the NHTSA. The complete details of all recalls are listed below, along with what they cover and the recommended solutions.

Recalls don't cost you anything to get fixed, but most are time-limited, so if your car is affected you should call your local Chevrolet service department immediately!

If you have questions about a recall, write down your VIN & then call Chevrolet customer service.

  1. RECALL: Fuel Filler Pipe Corrosion

    Significant corrosion may allow fuel to leak during refueling, and in the presence of an ignition source; there is an increased risk of fire. Read more »

    Date Announced
    AUG 08, 2012
    Vehicles Affected
  2. RECALL: FMVSS 108/Aftermarket Combination Lamps

    Decreased lighting visibility may result in a vehicle crash. Read more »

    Date Announced
    APR 07, 2009
    Vehicles Affected
  3. RECALL: Aftermarket Fuel Filters/Fuel Leak

    This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur. Read more »

    Date Announced
    MAY 19, 2006
    Vehicles Affected
  4. RECALL: Seat Belt Buckles

    In the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury. Read more »

    Date Announced
    DEC 19, 2005
    Vehicles Affected
  5. RECALL: Center High Mounted Stop Lamp/FMVSS 108

    Following vehicles may not be fully informed of vehicle braking. Rear-end crashes and injury to occupants may occur. Read more »

    Date Announced
    DEC 13, 2005
    Vehicles Affected
  6. RECALL: Hydro-Boost/Hydraulic Brake/Bosch

    If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. The presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause ... Read more »

    Date Announced
    FEB 08, 2005
    Vehicles Affected
  7. RECALL: GM/Transmission Shift Cable Separation

    If this were to occur, the vehicle could move in a direction not anticipated by the driver, which could result in a vehicle crash. Read more »

    Date Announced
    JUL 06, 2004
    Vehicles Affected
  8. RECALL: GM/FMVSS 209/Seat Belt Buckle Assembly

    The safety belt may not restrain the occupant as intended during a crash, which could result in injury to the occupant. Read more »

    Date Announced
    APR 19, 2004
    Vehicles Affected
  9. RECALL: GM/FMVSS 135/Brake Valve

    Consequently, the valve O-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture. ... Read more »

    Date Announced
    FEB 04, 2004
    Vehicles Affected

Browse Other Express Years

Become a Fan & Spread the Word