CarComplaints.com Notes: The 2002 Ford Explorer is hands-down our worst vehicle on record. "Avoid like the plague" is putting it lightly.
The 2002-2005 Explorer has a very well-established record of expensive transmission failure at under 100k miles. The Explorer has an enclosed transmission which is typically replaced with a rebuilt transmission at a cost of almost $3,000.
Another common problem for the 2002-2003 Explorer is wheel bearing failure at around 90k miles, with a typical repair bill of $500 to $1000 depending on how many wheel bearings failed.
Adding insult to injury, the 2002-2005 Explorer also has a massive problem with the rear panel cracking. While it's a minor annoyance compared to transmission failure, ironically the crack usually goes right through the Ford logo.
8.0
pretty bad
Typical Repair Cost:
No data
Average Mileage:
65,000 miles
Total Complaints:
1 complaints
Most Common Solutions:
check all switches in vehicle that light with the headlights (1 reports)
Headlight switch burned out twice due to the power door lock switch in the passenger door having an internal short. Am still surprised that the fuse system dosn't protect a $100 head light switch against such a thing.
A D V E R T I S E M E N T S
Headlight switch burned out twice due to the power door lock switch in the passenger door having an internal short. Am still surprised that the fuse system dosn't protect a $100 head light switch against such a thing.
- Eric M., Shippensburg, PA, US