Print this page

10.0

really awful
Crashes / Fires:
2 / 0
Injuries / Deaths:
2 / 0
Average Mileage:
5,949 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2020 Ford Explorer brakes problems

brakes problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2020 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

2020 Ford Explorer Owner Comments (Page 1 of 4)

problem #62

Jan 302024

Explorer

  • 40,000 miles

A D V E R T I S E M E N T S

The contact owns a 2020 Ford Explorer. The contact stated while driving at undisclosed speeds, the passenger-??s side rear brakes were scraping. There were no warning lights illuminated. The vehicle was taken to the local dealer for NHTSA Campaign Number: 23V675000 (Power Train). The vehicle was repaired; however, the brake failure persisted. The manufacturer was not notified about the failure. The failure mileage was approximately 40,000.

- Tupelo, MS, USA

problem #61

Jan 252024

Explorer

  • miles
We turned the vehicle on and a parking brake error came up on the dashboard followed by the dashboard lighting up with a lot of warnings. The vehicle was turned off and back on but continued with the error. Because we were out at a store and not home, we tried to drive it. We placed it in reverse and when put in drive, the brakes did not work with engaged. There was a small bumped that was able to stop the vehicle. I called Ford and they offered to run diagnostics on the vehicle for next week but could not guarantee a paid rental for the length of time needed for the repair. After exiting the vehicle, letting it rest for 5 minutes and restarting again, we were able to drive home with the brakes working again.

- Windermere, FL, USA

problem #60

Dec 312023

Explorer

  • miles
The rear left brake caliper locked up and caused damage to the wheel, tire, rotors and most of the brake assembly. Ford service thought that maybe a bolt fell out. The vehicle has ~36000 miles. I purchased what was called a bumper to bumper warranty from the dealership but was told it did not cover the problem. The damage is $3200. I looked at online forums and found numerous entries about the brake caliper issues. A parts employee at a dealership told me the part (L1MZ2B511C) was on national backorder due to a "Quality" problem. Ford customer service said they would not cover the repair because there is no recall.

- Plattsmouth, NE, USA

problem #59

Oct 012023

Explorer

  • 50,000 miles

A D V E R T I S E M E N T S

The contact owns a 2020 Ford Explorer. The contact stated that the brake warning light was illuminated. The brake pedal was engaged and continued to depress independently. After turning off the vehicle, an abnormal sound was detected. The contact stated that while driving, there was a line on the screen. The vehicle was taken to an independent mechanic and the contact was referred to the local dealer. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 50,000.

- Houston, TX, USA

problem #58

Oct 182023

Explorer

  • miles
Was at a complete stop heading Westbound on State Road 200 at Amelia Island Parkway (rd name?) at approximately 9:35 AM. I was behind a semi truck in the right hand lane. No one was ahead of him. There were two cars in the left hand lane, no one in the turning lane onto Amelia Island Parkway. I decided to get into the left lane behind those two cars so I wasn-??t stuck behind the semi. I very slowly moved to the left lane, pushed on the brake the first time and kept moving, second time pushed as hard as I could and kept rolling, now close to hitting the car ahead of me. I immediately put the vehicle in park and which also activated the parking brake. The light turned green and I put the car back into drive and drove no faster than probably 45 mph. Stopped into the ulta parking lot parked and called Paul Clark Ford who insisted I bring the car in right away. Drove approx 2-5 min to Paul Clark Ford slowly. Ford was not able to reproduce the issue. No warning lamps came on.

- Fernandina Beach, FL, USA

problem #57

Apr 042020

Explorer

  • miles
In April 2020, I brought my car into the Lafayette Ford Dealership in Fayetteville, NC bc I had been experiencing issues with the car moving when it was not supposed to. I would start the car with my foot on the brake, switch it into reverse/drive and *without taking my foot off the brake* the car would jerk forward or back, depending on if I was in reverse or drive. The event that caused me to bring my car into the dealership occured while I was in front of my garage. I had my foot on the break, and was planning to adjust my direction toward the garage when my car propelled forward and took a hit that resulted in bad damage to my driver side bumper. The dealership held my car for over a week and was not able to replicate the problem, so they told me my car was fine. I have since mentioned this problem every time I get my car serviced to see if there have been any similar complaints and nobody has shared anything. At my last service appointment, they updated my firmware so that the car keeps the emergency brake on until I disengage it, which nullifies the issues that I had been having. Today I can across the following article that sounds exactly like the cause of the damage to my car. What are my options for taking this information to Ford to have them acknowledge the fault and fix the damage? Thank you. https://www.usatoday.com/story/money/cars/2023/06/25/ford-explorer-recall-investigation-nhtsa/70354653007/

- Freeport, FL, USA

problem #56

Aug 222023

Explorer

  • 45,200 miles

A D V E R T I S E M E N T S

The contact owns a 2020 Ford Explorer. The contact stated while his wife was driving at an undisclosed speed down a steep driveway, upon depressing the brake pedal, the vehicle failed to come to a complete stop. The driver was able to bring the vehicle to a complete stop by shifting into park. The hill stop control and ABS warning lights were illuminated. The vehicle was taken to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 45,200.

- Akron, OH, USA

problem #55

Aug 082023

Explorer

  • miles
After starting vehicle it rolled when placed out of park while foot was on break and the emergency break was still engaged. There was no pressure and all warning lights associated with pre-collision, hill start, and antilock break fault were flashing across screen only while trying to stop and break from rolling. My safety and others was at risk by rolling into the street i could have been hit by oncoming cars or unable to stop from hitting anyone. My vehicle is maintained at dealer and is kept up on all service and recalls requirements. After vehicle was towed to dealer they were able to find the following TSB https://static.nhtsa.gov/odi/tsbs/2020/MC-10177885-0001.pdf Lives are not a technical service bulletin they are a RECALL.

- Merritt Island, FL, USA

problem #54

Jun 162023

Explorer

  • miles
For months our backup camera would turn blue and not show the rear cameras. Also during this time, on occasion the emergency braking would stop us from backing up and then the brakes would not work. We had a recall on the blue screen software but the breaking has started again.

- Westminster, CO, USA

problem #53

Sep 152022

Explorer

  • 20,000 miles
The contact owns a 2020 Ford Explorer. The contact stated that on various occasions after starting the vehicle, the brake system warning light illuminated. The contact stated that the warning light disappeared after driving; however, the failure persisted whenever starting the vehicle. The vehicle was taken to a local dealer, where the failure could not be duplicated. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 20,000.

- Leighton, AL, USA

problem #52

Dec 192022

Explorer

  • miles

A D V E R T I S E M E N T S

I started my car via remote start and after entering the vehicle, I hit the start button, depressed the brake and turned the transmission to reverse. Upon rolling back, I noticed the brakes felt funny, not completely stopping me as they should with the amount of pressure I was applying. I proceeded start driving thinking the brakes my fix themselves after letting off and driving forward. I then began to hear dinging, prompting me to look at the dash. It was flashing a bunch of errors: -??hill start assist not available-??, -??Pre-collision assist not available-??, -??service advance trac-??, -??check brake system-??, -??hill descent Control fault-??, 4WD fault service required-??, -??Park Break limited function service required-??. As I was driving down the road with all of this flashing/ dinging and brakes not completely working, I noticed my emergency brake was on as well. I never use the emergency brake and am unsure how it was switched on. I was able to pull over about a minute down the road and turned the car off and then back on. I tried again to start driving, but had to pull over again 100-200 feet down the road because the dinging, notifications, and brake issues continued. At this point I again, turned the car off and back on. This time it cleared the issue and no more dinging, notifications, or brake issues. This has happened about 3 times. After the first time, i mentioned it to the dealer when servicing my car, but they were unable to find any problems. Each time this happens, i am able to clear it with a restart. I seem to notice it happens with colder temps (under 40 degrees).

- Aldie, VA, USA

problem #51

Jan 282023

Explorer

  • miles
Drivetrain failure. Vehicle rolled forward while turned off, in park, while on a hill. Break did not respond while rolling (passenger who was still in car tried to lean over the seat to depress the break). Driver ran from behind the vehicle, hopped in (while car was moving!), turned car on, applied break and veered the vehicle right to get the car to stop. Vehicle nearly collided with three pedestrians and a nearby parked car. We have brought this car in to a Ford Dealership today. We reported a shuttering that occurred during peak torque while in for service last year - but dealership said they could not replicate.

- Huntington Woods, MI, USA

problem #50

Aug 262022

Explorer

  • miles
I hit my brakes at a traffic light and the dash board lite up. With the following messages. Service Advance trac, 4WD Fault service required, see manual, hill start asst not available, auto hold fault, tooknto dealer tried to charge $600 for a diagnostic, codes were ran all codes are communication codes. Have no abs brakes. Took to another shop they couldn't figure it out. Called Ford. They refer back to dealer who what's to charge more money for diagnostics and the 33 codes they say are in the computer. Big safety issues. Happened just after 60,000 miles before looking at it dealer stated it wouldn't be covered under powertrain warranty anyway. Can't upload photos from phone for some reason.

- Columbus, OH, USA

problem #49

Dec 242022

Explorer

  • miles
Braking system stopped working. I had no breaks on the Highway! All systems lit up on my dash. Thankfully I was able to coast down the side of road in neutral until the car stopped. Whole time I was holding the brake down to the floor. Upon stopping it automatically threw into park. I turned the car off and then started again and everything seemed fine. I was scared to death to even drive it any further. I took it to the dealership to have it looked at. I see this is a problem with 2020 explorers and it needs to recalled. Someone is going be seriously injured or even die in the event of a wreck from this issue

- Laurel, MS, USA

problem #48

Mar 142021

Explorer

  • miles
On March 14, 2021, a failure with the vehicle posed a serious safety hazard when my two children, another minor child and our dog were accompanying me, with the car fully loaded for spring break, and the brake system completely failed, among other electrical issues, as we were departing our neighborhood. The vehicle was subsequently towed to the dealership. I cringe to imagine what would have ensued if this defect would have occurred only a few minutes later, as we pulled into traffic or made it to the highway for our trip. I don't recall what lamps came on as it was very scary at the time, but the alerts on the Ford App were, Antilock Brake Fault, Hill Start Assist Warning, Hill Descent Control Fault Warning and Pre-Collision Assist Not Available.

- League City, TX, USA

problem #47

Sep 172022

Explorer

  • miles
When shifting from park to reverse, with foot completely on brake, the car will roll backwards several feet before stopping. Happens multiple times a month. Very dangerous as it rolls back into oncoming vehicles in parking lots. It is difficult to replicate as it is an intermittent problem. There is no prompting by the vehicle that there is an issue before hand. The only notable difference is the brakes are very firm while the vehicle is rolling and cannot be pressed in further.

- Lincoln, CA, USA

problem #46

Aug 012022

Explorer

  • miles
When I release the parking brake and put the car in reverse, the car starts to roll while my foot is still actively pressing the brake. Brake pedal feels locked. It-€™s happened a handful of times but is not consistent and hard to replicate. This, of course, puts anyone in my car in danger and anyone around my car. I-€™ve taken it to the dealership and elevated it to corporate, but they say they can-€™t do anything since they can-€™t replicate it on site. Based on website forums, this is a common issue. When it happens, there are no warning lights or anything indicators. Again, to summarize, car rolls when brake is pressed intermittently.

- Maryville , TN, USA

problem #45

Jun 212022

Explorer

  • 19,624 miles
The contact owns a 2020 Ford Explorer. The contact stated that while having a routine oil change completed at the local dealer, she was informed about a recall update. The contact stated that while driving, the electronic parking brake engaged. The contact stated that the failure had occurred while the vehicle was in park(P) and also while driving. While shifting into drive or reverse, the vehicle was jerking. The Auto START/STOP was disengaged. Additionally, the brakes were continuously grabbing while attempting to stop the vehicle. There were no warning lights illuminated. The vehicle was taken back to the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA. The approximate failure mileage was 19,624.

- Pontiac, IL, USA

problem #44

Jan 172022

Explorer

  • 15,000 miles
The contact owns a 2020 Ford Explorer. The contact stated while driving approximately 20 MPH and slowing down for a traffic light he had a brake failure and crashed at low speed into the rear of a vehicle already stopped at the traffic light. The contact stated that he was pumping the brakes and was not able to stop. The contact stated no warning light was illuminated. The contact stated that there was damage to the right front passenger side of his vehicle and was unable to determine the damage to the other vehicle. The police were called and wrote a report. There were no injuries and the contact had the vehicle towed to his home and later towed to a dealer. The local dealer diagnosed that there were no problems with the brakes. The vehicle damage was repaired but not the brakes. The manufacturer had been informed of the failure. The failure mileage was approximately 15,000.

- Marina Del Rey, CA, USA

problem #43

Mar 312022

Explorer

  • miles
My car warnings were malfunctioning as they were all flashing on briefly. The car has done this before and has other issues with the panel such as now it has the icon for camera visibility is not working. I cleaned each camera and the light is still on. I backed out of the driveway put the car in drive and started to accelerate. I stepped on the brakes and they were not working, I repeatedly tried to stop but they were gone. My car finally stopped (I was not far enough to have started to build any speed. I turned the car off and back on and the brakes were back on. This happened March 31st, 2022.

- Plumas Lake, CA, USA

Read the next 20 complaints »

Not what you are looking for?