[ switch models ] 2003 Pontiac Aztek 2003 Pontiac Bonneville 2003 Pontiac Grand Prix 2003 Pontiac Montana 2003 Pontiac Sunfire 2003 Pontiac Vibe [ switch years ] 2007 Pontiac Grand Am 2005 Pontiac Grand Am 2004 Pontiac Grand Am 2002 Pontiac Grand Am 2001 Pontiac Grand Am 2000 Pontiac Grand Am 1999 Pontiac Grand Am 1998 Pontiac Grand Am 1997 Pontiac Grand Am 1996 Pontiac Grand Am 1995 Pontiac Grand Am 1994 Pontiac Grand Am 1993 Pontiac Grand Am 1992 Pontiac Grand Am 1991 Pontiac Grand Am 1990 Pontiac Grand Am 1989 Pontiac Grand Am 1987 Pontiac Grand Am 1986 Pontiac Grand Am

2003 Pontiac Grand Am

Technical Service Bulletins

There are also 3 Pontiac recalls » 142 TSBs » for the Pontiac Grand Am.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #040232001 -- RELEASE OF STEERING GEAR STUB SHAFT BEARING KIT FOR SERVICE. *TT UPDATED 08-15-07. *KB UPDATED 10/09/07. *NJ (NHTSA ID #10012694, AUGUST 01 2007)
• TSB #030232001B -- MOMENTARY REDUCTION OF POWER STEERING PS ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. THIS SERVICE BULLETIN REPLACES 030232001A. *EH (NHTSA ID #10012093, JULY 01 2004)
• TSB #030236002 -- REVISED STEERING WHEEL POSITION SENSOR OR STEERING SHAFT LOWER BEARING REPLACEMENT PROCEDURE AND STEERING WHEEL POSITION SENSOR CENTERING PROCEDURE. *EH (NHTSA ID #10012577, AUGUST 01 2003)

STEERING:COLUMN

• TSB #060235019 -- REVISED TILT STEERING WHEEL AND COLUMN FASTENER TIGHTENING SPECIFICATIONS. *KB (NHTSA ID #10020731, SEPTEMBER 01 2006)

STEERING:HYDRAULIC POWER ASSIST SYSTEM

• TSB #030232001A -- MOMENTARY REDUCTION ON POWER STEERING (P/S) ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. *TT (NHTSA ID #10004762, OCTOBER 01 2003)
• TSB #022403 -- INTERMITTENT CONDITION OF A MOMENTARY REDUCTION IN POWER STEERING ASSIST AT STARTUP. *TT *JB (NHTSA ID #10001842, FEBRUARY 24 2003)

STEERING:LINKAGES:TIE ROD ASSEMBLY

• TSB #030232049 -- RELEASE OF NEW OUTER TIE ROD ENDS FOR SERVICE. *TT (NHTSA ID #10004765, NOVEMBER 01 2003)

SUSPENSION

• TSB #040308015A -- SQUEAKING NOISE IN FRONT END ON TURNS. *TT (NHTSA ID #10011062, MAY 01 2005)
• TSB #040308010 -- CHANGES TO LABOR TIME GUIDE RELATING TO FRONT SUSPENSION LABOR OPERATIONS COMPONENTS. *EH (NHTSA ID #10012182, JUNE 01 2004)
• TSB #020308008 -- RATTLE, CREAK, POPPING TYPE NOISE FROM FRONT OF VEHICLE WHEN TURNING. *TT (NHTSA ID #10000465, NOVEMBER 01 2002)
• TSB #020310004 -- A NEW IMPROVED FLAT WHEEL MOUNT DESIGN FOR 2003 MODEL YEAR ALUMINUM WHEELS. *TT (NHTSA ID #634870, JULY 01 2002)
• TSB #3263 -- FRONT SUSPENSION NOISE ON TURNS. *EH (NHTSA ID #10011819, no date provided)

SUSPENSION:FRONT

• TSB #02139 -- SQUEAK OR RUB TYPE NOISE ON TURNS COMING FROM THE FRONT SUSPENSION AS IF IT IS COMING FROM THE SHOCK ABSORBER OR THE TOP MOUNT. *TT (NHTSA ID #10008871, JANUARY 01 2004)

SUSPENSION:FRONT:WHEEL BEARING

• TSB #021303 -- FRONT WHEEL BEARING REPLACEMENT. *TT (NHTSA ID #10002550, FEBRUARY 13 2003)

SERVICE BRAKES, HYDRAULIC

• TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)
• TSB #050523001 -- REVISED BRAKE SYSTEM SPECIFICATIONS. *TT (NHTSA ID #10014985, MARCH 01 2005)
• TSB #040523004 -- BRAKE NOISE/CREAK DURING SLOW SPEED BRAKING. ALSO INCLUDES 2004 CHEVROLET MALIBU CLASSIC. *TT (NHTSA ID #10011052, SEPTEMBER 01 2004)
• TSB #3003 -- BRAKE NOISE/CREAK DURING SLOW SPEED BRAKING. *MJ (NHTSA ID #10008862, JANUARY 01 2004)
• TSB #061303 -- A REVIEW OF WARRANTY DATA AND PARTS SENT BACK TO THE WARRANTY PARTS CENTER INDICATES THAT BRAKE ROTORS AND PADS ARE BEING REPLACED FOR PRESALE LOT ROT CORROSION ISSUES. *TT (NHTSA ID #10003704, JUNE 17 2003)
• TSB #000523002B -- FRONT DISC BRAKE PULSATION. *TT (NHTSA ID #10001251, MARCH 01 2003)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

• TSB #021803 -- METAL RATTLE TYPE NOISE FROM THE REAR OF THE VEHICLE. CAUSED BY A LOOSE ATTACHMENT SPRING CLIP AT THE REAR BRAKE LINE HOSE BRACKET. THIS CLIP IS SECURED PROPERLY, BUT MAY NOT PROVIDE ENOUGH SPRING TENSION, WHICH ALLOWS IT TO RATTLE AGAI (NHTSA ID #10002556, FEBRUARY 18 2003)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

• TSB #022603 -- BRAKE PAD REPLACEMENT. *TT *JB (NHTSA ID #10001848, FEBRUARY 26 2003)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

• TSB #04082004 -- THE CURRENT BRAKE ROTOR MINIMUM ALLOWABLE THICKNESS AFTER REFINISH, OR MINIMUM THICKNESS SPECIFICATION, FOUND IN THE PAST SERVICE MANUAL APPLICATIONS ARE INCORRECT. PLEASE USE CORRECT INFORMATION AS FOLLOWS. *TT (NHTSA ID #10009210, APRIL 08 2004)

SERVICE BRAKES, HYDRAULIC:ANTILOCK:ABS WARNING LIGHT

• TSB #3192 -- THE ANTI-LOCK BRAKE SYSTEM INDICATOR IS ILLUMINATED AND DIAGNOSTIC TROUBLE CODE C1236 IS STORED. *TT (NHTSA ID #10010632, no date provided)

SERVICE BRAKES, AIR

• TSB #070201 -- INCORRECT OUTER BACKING PLATE. OUTER BACKING PLATE HAS SHORT CENTRE PROTUSION. OUTER BACKING PLATE SHOULD HAVE TALL CENTER PROTRUSION. *KB (NHTSA ID #10021412, MARCH 01 2007)
• TSB #3169 -- BRAKES CALIPER NOISE ON APPLY. *EH (NHTSA ID #10010551, no date provided)
• TSB #4615 -- ABS PUMP RUNNING WHEN NOT NEEDED. *NJ (NHTSA ID #10023171, no date provided)

SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

• TSB #04152004 -- VEHICLES MAY SET ANYONE OR A COMBINATION OF FRONT-WHEEL SPEED SENSOR ANTI-LOCK BRAKE SYSTEM CODES AS INTERMITTENT OR HARD FAILURES. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10009220, APRIL 15 2004)
• TSB #00966 -- ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007816, JANUARY 01 2004)
• TSB #00966B -- ABS FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007293, JANUARY 01 2004)
• TSB #3477 -- TECH 2 DISPLAYS ASTERISK FOR THE LEFT FRONT WHEEL SPEED SENSOR. *TT (NHTSA ID #10014875, no date provided)

ENGINE AND ENGINE COOLING

• TSB #709 -- OIL LIFE SYSTEM RESET PROCEDURES - CARS. GM TECH LINK. *TT (NHTSA ID #10018126, SEPTEMBER 01 2005)
• TSB #050601003A -- HIGHER THAN EXPECTED OIL CONSUMPTION BLUE SMOKE ON ACCELERATION. *EH (NHTSA ID #10013473, AUGUST 01 2005)
• TSB #050604002 -- WHISTLE NOISE ON LIGHT ACCELERATION. *EH (NHTSA ID #10013475, JANUARY 01 2005)
• TSB #04092 -- ACCELERATOR CONTROL SYSTEM. *EH (NHTSA ID #10014004, NOVEMBER 01 2004)
• TSB #610 -- ENGINE IDLE FLARE WHEN THE CLUTCH IS DEPRESSED. ALSO LOW SPEED ENGINE DECEL STALL WHEN COMING TO A STOP. GM TECH LINK. *TT (NHTSA ID #10015768, OCTOBER 01 2004)
• TSB #030601018 -- NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. THIS SERVICE BULLETIN REPLACES 030601018A. *EH (NHTSA ID #10012103, JULY 01 2004)
• TSB #3114 -- B1327 DIAGNOSTIC MISSING. *SC (NHTSA ID #10009973, JANUARY 01 2004)
• TSB #030601010 -- ENGINE OIL OR COOLANT LEAK. *TT (NHTSA ID #10001282, MARCH 01 2003)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #03-06-01-010 -- ENGINE OIL OR COOLANT LEAK. *TT GM REMINDER. *TT INSTALL NEW LOWER INTAKE MANIFOLD GASKET. UPDATED 7/18/08 *PE (NHTSA ID #10004768, APRIL 01 2008)
• TSB #030604030 -- MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT (NHTSA ID #10002166, MARCH 01 2007)
• TSB #050604026 -- VEHICLE HESITATES, NO START, LACK OF POWER, LOW FUEL PRESSURE. *TT (NHTSA ID #10017407, MAY 01 2005)
• TSB #040604063 -- ENGINE IDLE FLAIR WHEN CLUTCH DEPRESSED OR DECEL STALL. *TT (NHTSA ID #10011046, SEPTEMBER 01 2004)
• TSB #0804 -- OIL LIFE SYSTEM RESET PROCEDURES - CARS. *NM (NHTSA ID #10014346, AUGUST 01 2004)
• TSB #01995 -- REPLACING A 02 OR 03 2.2L L61 WITH A 04 2.2L L61 ENGINE REPLACEMENT.*MR (NHTSA ID #10007055, JANUARY 01 2004)
• TSB #01525 -- ENGINE STALL HESITATION STUMBLE WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT (NHTSA ID #10005461, JANUARY 01 2004)
• TSB #00434 -- ENGINE WILL CRANK BUT NOT START, ALSO MAKES NOISE WHILE CRANKING. 2.2 L61 ENGINE. *TT (NHTSA ID #10007528, JANUARY 01 2004)
• TSB #01353 -- ENGINE MISFIRE DUE TO INJECTOR FRETTING CORROSION. *TT (NHTSA ID #10007937, JANUARY 01 2004)
• TSB #01527 -- A WHISTLE TYPE NOISE COMING FROM THE ENGINE. SIT BULLETIN 1406534. *TT (NHTSA ID #10005464, JANUARY 01 2004)
• TSB #030601022 -- GUIDELINES FOR CYLINDER BORE LINER/PISTON SLEEVE REPLACEMENT ON THE L4 ECOTEC ENGINE. *TT (NHTSA ID #10011117, JANUARY 01 2004)
• TSB #01556 -- ENGINE CRANKS BUT DOES NOT RUN. *TT (NHTSA ID #10005396, JANUARY 01 2004)
• TSB #3014 -- STALL, HESITATION, STUMBLE WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT (NHTSA ID #10008776, JANUARY 01 2004)
• TSB #03064 -- ON-BOARD DIAGNOSTIC SYSTEM SOFTWARE UPGRADE - OBD SYSTEM IMPROVEMENTS. *TT (NHTSA ID #10005744, DECEMBER 01 2003)
• TSB #071103 -- THIS VME MESSAGE CONCERNS A CYLINDER BORELINER TOOL NOW AVAILABLE FOR THE L61 2.2 LITER ENGINE. THE TOOL IS REFERENCED IN SERVICE BULLETIN 030601018. THE PURPOSE OF THE TOOL IS TO EXTEND THE TOTAL SERVICE LIFE OF THE BLOCK. *TT (NHTSA ID #10003816, JULY 11 2003)
• TSB #030601018 -- NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. *TT (NHTSA ID #10002130, JUNE 01 2003)
• TSB #052203 -- COMPLAINTS OF INTERMITTENT VEHICLE SHUTTING OFF WHILE DRIVING WITH NO MULTIPLE CODES SET. THE VEHICLE WOULD IMMEDIATELY RESTART. THE ACTUAL CAUSE OF THIS CONDITION WAS THAT OVER BUMPS THE MASS AND WEIGHT OF THE CUSTOMER'S KEY RING FORCES (NHTSA ID #10003658, MAY 22 2003)
• TSB #09222002 -- NO START STARTER NOISE; NO START CONDITION. FEEDBACK FROM POWERTRAIN ENGINEERING. *TT (NHTSA ID #10009497, OCTOBER 22 2002)
• TSB #3859 -- LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ (NHTSA ID #10020923, no date provided)
• TSB #3433 -- SERVICE ENGINE SOON (SES) LIGHT AND SEVERE ENGINE MISFIRE ON CYLINDERS 1 AND 4 OR CYLINDERS 2 AND 3. *TT UPDATED 08-15-07. *KB (NHTSA ID #10017032, no date provided)
• TSB #3709 -- SUPPLEMENT TO ENGINE REPLACEMENT INSTRUCTIONS FOR PART NUMBER 12607031. *TT (NHTSA ID #10019420, no date provided)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #071503 -- COOLANT LOSE, EVIDENCE FLUID ON THE GARAGE FLOOR, ETC., OR COOLANT WARNING LIGHT COMING ON. *TT (NHTSA ID #10003789, JULY 15 2003)
• TSB #071003 -- THIS VME MESSAGE IS A WATER PUMP REPLACEMENT DUE TO A KNOWN CAM DRIVELINE. SOME CUSTOMERS MAY QUESTION ABOUT WHINE NOISE COMING FROM THE FRONT ENGINE AREA. *TT (NHTSA ID #10003815, JULY 10 2003)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

• TSB #031203 -- BUFFETING OR ROTATIONAL TYPE TICK NOISE FROM HVAC BLOWER MOTOR AREA. *TT *JB (NHTSA ID #10001909, MARCH 12 2003)

FUEL SYSTEM, GASOLINE

• TSB #031103 -- COMPLAINTS THAT ARE ROOT CAUSED TO THE FUEL MODULE AND COMPLAINTS OF GAUGE ACCURACY THAT ARE ROOT CAUSED TO THE FUEL LEVEL SENSOR. *TT *JB (NHTSA ID #10001904, MARCH 11 2003)

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

• TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)

POWER TRAIN

• TSB #01604 -- 4T40E, 4T45E CHANGE IN APPEARANCE OF FORWARD, SECOND AND REVERSE CLUTCH WAVE PLATE. *TT (NHTSA ID #10007135, JANUARY 01 2004)
• TSB #030730021 -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10002392, MAY 01 2003)
• TSB #020730050 -- ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR 4T45E TRANSAXLES AND SUBSEQUENT OVERHAUL PROCEDURES WHICH AFFECT 1995-2001 MODEL YEAR TRANSAXLES. *TT (NHTSA ID #10000759, DECEMBER 01 2002)
• TSB #3447 -- 4T40E OR 4T45E WILL NOT SHIFT NO DIAGNOSTIC TROUBLE CODES. *TT (NHTSA ID #10017086, no date provided)

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE

• TSB #01522 -- CLUTCH PEDAL STAYS TO FLOOR REPEAT SLAVE CYLINDER FAIL. SIT BULLETIN 1405756. *TT (NHTSA ID #10005459, JANUARY 01 2004)
• TSB #3915 -- CLUTCH PEDAL STAYS TO FLOOR. *TT (NHTSA ID #10019423, no date provided)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #070730025 -- INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ (NHTSA ID #10023942, OCTOBER 01 2007)
• TSB #030730012A -- TRANSAXLE OR TRANSMISSION SLIPS, WON'T SHIFT, NO REVERSE, 2ND, 3RD OR OVERDRIVE, ERRATIC SHIFTS. *TT (NHTSA ID #10004722, AUGUST 01 2005)
• TSB #020730039E -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT UPDATE. *TT (NHTSA ID #10004756, AUGUST 01 2005)
• TSB #01477 -- 4T45E 4T40E AUTOMATIC TRANSMISSION FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1815. *TT (NHTSA ID #10005512, JANUARY 01 2004)
• TSB #030730021A -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10005579, NOVEMBER 01 2003)
• TSB #020730039C -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT (NHTSA ID #10002840, JUNE 01 2003)
• TSB #01432 -- AUTOMATIC TRANSMISSION POOR ACCELERATION, PERFORMANCE. *TT (NHTSA ID #10004412, JANUARY 01 2003)
• TSB #020730039A -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT (NHTSA ID #10000773, DECEMBER 01 2002)
• TSB #020730044 -- ERRATIC SPEEDOMETER, ERRATIC SHIFTING, CRUISE CONTROL INOPERATIVE, DIAGNOSTIC TROUBLE CODE P0502, P0758, P1860 SET. *TT (NHTSA ID #10000460, NOVEMBER 01 2002)
• TSB #3669 -- M86/M94 TRANSMISSION INFORMATION TO DISASSEMBLE THIRD FOURTH AND FIFTH GEAR. *AK (NHTSA ID #10019228, no date provided)
• TSB #3253 -- VEHICLE WILL NOT MOVE IN EITHER DIRECTION. TRANSMISSION MAY SHOW OVER FULL. P90 4T40E 4T45E NO MOVEMENT DRIVE OR REVERSE. CONVERTER MAY BE EMPTY OF FLUID. *TT (NHTSA ID #10017096, no date provided)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #022003 -- REPEAT CONDITION OF THE POWERTRAIN CONTROL MODULE (PCM), DIAGNOSTIC TROUBLE CODE (DTC) P0130, WHICH IS PCM DETECTED TO LOOP STATUS WAS OPEN TOO LONG. ENGINEERING WOULD LIKE TO INSPECT ANY VEHICLE BEFORE THE ACTUAL REPAIR HAS BEEN PERFORME (NHTSA ID #10002566, FEBRUARY 20 2003)

POWER TRAIN:AXLE ASSEMBLY

• TSB #010303 -- INFORMATION USED WHEN SERVICING THE DRIVE AXLE NUT. *TT (NHTSA ID #10002587, JANUARY 03 2003)
• TSB #020730048 -- PRESSURE CONTROL SOLENOID REPLACEMENT FOR 4T65-E, 4T40-E, AND 4T45-E TRANSAXLE/TRANSMISSION.*MR (NHTSA ID #10006166, NOVEMBER 02 2002)

ELECTRICAL SYSTEM

• TSB #3055 -- HARNESS CHAFFING ON INSTRUMENT PANEL TO KNEE BOLSTER BRACKET CAUSING NUMEROUS ELECTRICAL CONDITIONS. *TT (NHTSA ID #10009595, JANUARY 01 2004)
• TSB #01758 -- CODE B1327 DIAGNOSTICS MISSING. *MR (NHTSA ID #10006382, JANUARY 01 2004)
• TSB #021903 -- ENGINEERING WOULD LIKE TO INSPECT ANY VEHICLE BEFORE THE ACTUAL REPAIR IS PERFORMED WHEN THE REPAIR DIAGNOSIS LEADS TO REPLACING THE BODY CONTROL MODULE (BCM), FOR BATTERY DRAIN, INTERMITTENT NO START, IPC DISPLAY INTERMITTENTLY INTERRUPTED (NHTSA ID #10002560, FEBRUARY 19 2003)
• TSB #09242002 -- ERRATIC SPEEDOMETER, POSSIBLE TRANSMISSION NO SHIFT AND/OR CRUISE CONTROL INOPERATIVE. *TT (NHTSA ID #10008625, SEPTEMBER 24 2002)
• TSB #3055 -- NUMEROUS ELECTRICAL CONDITIONS WHICH INCLUDE WINDSHIELD WIPERS, TURN SIGNAL LAMPS, AIR BAGS, STOP LAMPS, AND HAZARD LAMPS. *KB (NHTSA ID #10021347, no date provided)

ELECTRICAL SYSTEM:WIRING

• TSB #01740 -- CROSS INJECTOR WIRES CAUSING MISFIRE AT STEADY STATE SPEED AND RPM, MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED, AND A P0300 SET. SIT BULLETIN 1460291. *TT (NHTSA ID #10006270, JANUARY 01 2004)

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

• TSB #3648 -- HESITATION ON ACCELERATION AFTER INTERNAL ENGINE REPAIRS - CHECK INJECTOR HARNESS ORIENTATION. *TT (NHTSA ID #10018915, no date provided)

ELECTRICAL SYSTEM:IGNITION

• TSB #022003 -- ENGINEERING WOULD LIKE TO INSPECT ANY VEHICLE BEFORE THE ACTUAL REPAIR HAS BEEN PERFORMED WHERE THE REPAIR DIAGNOSIS LEADS TO REPLACING THE IGNITION LOCK CYLINDER FOR AN INTERMITTENT OR HARD NO START TYPE OF CONDITION OR CUSTOMER COMPLAINT. (NHTSA ID #10002562, FEBRUARY 20 2003)

EXTERIOR LIGHTING

• TSB #200602 -- SOME CUSTOMERS MAY COMMENT THAT A STOP AND / OR TAIL LAMP MAY NOT WORK CORRECTLY OR THAT THE LAMP ASSEMBLY HAS WATER IN IT. *TT (NHTSA ID #637248, JUNE 20 2002)

EXTERIOR LIGHTING:TAIL LIGHTS

• TSB #000842007B -- SOME CUSTOMERS MAY COMMENT THAT A STOP AND / OR TAIL LAMP MAY NOT WORK CORRECTLY, OR THAT THE TAIL LAMP HAS WATER IN IT. TO INCLUDE CHEVROLET CLASSIC 2005. *TT (NHTSA ID #634995, AUGUST 01 2004)
• TSB #000842007 -- STOP TAIL LAMP INOPERATIVE OR INTERMITTENT AND OR WATER IN LAMP. *EH (NHTSA ID #10012147, JUNE 01 2004)

VISIBILITY

• TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)

VISIBILITY:GLASS, SIDE/REAR

• TSB #010864012D -- DOOR GLASS SASH OUT OF RUN CHANNEL. *TT UPDATE. *TT (NHTSA ID #10004355, MARCH 01 2005)
• TSB #010864018D -- FRONT DOOR WINDOW GLASS WON'T ROLL UP OR OUT OF CHANNEL. *TT (NHTSA ID #10004753, OCTOBER 01 2003)
• TSB #010864018B -- FRONT DOOR WINDOW GLASS WON'T ROLL UP OR OUT OF CHANNEL. *TT (NHTSA ID #10001133, FEBRUARY 01 2003)
• TSB #010864012C -- DOOR GLASS SASH OUT OF RUN CHANNEL. *TT (NHTSA ID #10001131, FEBRUARY 01 2003)
• TSB #11082002 -- THE DOOR WINDOW GLASS WILL NOT ROLL UP OR IT IS OUT OF THE CHANNEL. *TT (NHTSA ID #10008618, NOVEMBER 08 2002)
• TSB #11072002 -- THE DOOR GLASS IS OUT OF THE RUN CHANNEL OR INOPT. *TT (NHTSA ID #10008617, NOVEMBER 07 2002)

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

• TSB #040864020 -- FRONT DOOR POWER WINDOW INOPERATIVE. *TT (NHTSA ID #10012744, OCTOBER 01 2004)
• TSB #020864023A -- POWER WINDOW INOPERATIVE. *TT (NHTSA ID #10004359, AUGUST 01 2003)
• TSB #030803 -- UNNECESSARY REPLACEMENT OF DOOR WINDOW REGULATORS. *TT *JB (NHTSA ID #10001887, MARCH 08 2003)
• TSB #020864023 -- POWER WINDOW INOPERATIVE. *TT (NHTSA ID #10000756, DECEMBER 01 2002)

VISIBILITY:SUN ROOF ASSEMBLY

• TSB #030867009 -- SUNROOF WILL NOT OPEN OR CLOSE COMPLETELY DUE TO THE SUNROOF MOTOR. *TT (NHTSA ID #10005595, MARCH 01 2004)
• TSB #02042 -- SUNROOF NOT OPERATING PROPERLY. *MR (NHTSA ID #10006913, JANUARY 01 2004)
• TSB #01598 -- SUNROOF SUPPLEMENTAL INFORMATION TO 03-08-67-009.*MR (NHTSA ID #10007178, JANUARY 01 2004)
• TSB #100903 -- JAMMED SUNROOF THAT WILL NOT OPEN OR CLOSE COMPLETELY REVISITED. GM VOICEMAIL LOG. *TT (NHTSA ID #10004987, OCTOBER 09 2003)
• TSB #030867004 -- PARTS AVAILABILITY FOR SUNROOF REPAIRS. *TT (NHTSA ID #10002878, JUNE 01 2003)

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

• TSB #020843005 -- NEW WINDSHIELD WIPER MOTOR ASSEMBLY. *TT (NHTSA ID #10000727, DECEMBER 01 2002)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER

• TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)
• TSB #01262004 -- THIS IS A PRODUCT SERVICE MESSAGE REGARDING THE NEW PART NUMBER FOR THE HEATER BLOWER RESISTOR FOR CUSTOMER CONCERN OF THE HEATER MOTOR NOT BLOWING ON ONE UP TO ALL SPEEDS. *TT (NHTSA ID #10012980, JANUARY 26 2004)

SEAT BELTS

• TSB #030940003 -- SEAT BELT LIGHT STAYS ON OR FLICKERS AFTER SEAT BELT IS BUCKLED. *TT (NHTSA ID #10002128, JUNE 01 2003)

STRUCTURE:BODY

• TSB #030850016 -- PAINT FLAKES ON FRONT CARPET, FRONT SEAT FRAME PAINT FLAKING OFF. *TT (NHTSA ID #10004779, OCTOBER 01 2003)
• TSB #030867005 -- WATER ON FRONT FLOOR. *TT (NHTSA ID #10012580, JULY 01 2003)
• TSB #030866002 -- WIND NOISE HEARD FROM REAR OF VEHICLE. *TT (NHTSA ID #10000945, JANUARY 01 2003)
• TSB #050602 -- THIS INFORMATION CONCERNS VEHICLES WITH THE SET APPEARANCE PACKAGE. *TT (NHTSA ID #637193, JUNE 05 2002)

STRUCTURE:BODY:DOOR

• TSB #010864020C -- A CREAK OR SQUEAK NOISE WHEN OPENING OR CLOSING ONE OF MORE DOORS. *TT THIS BULLETIN REPLACES PREVIOUS BULLETIN 01-08-64-020 DATED 12/01/2001. *TT THIS BULLETIN REPLACES 01-08-64-020B. *TT (NHTSA ID #628894, OCTOBER 01 2004)
• TSB #250702 -- SOME CUSTOMERS MAY COMMENT THAT THE EXTERIOR DOOR HANDLE IS INOPERATIVE ON CERTAIN VEHICLES. *TT (NHTSA ID #637316, JULY 25 2002)

STRUCTURE:BODY:ROOF AND PILLARS

• TSB #052303 -- AFTER A HEAVY RAIN MOISTURE IS PRESENT AROUND THE A PILLAR FRONT COWL OR FRONT FLOOR AREA ON VEHICLES BUILT WITH A SUNROOF. *TT (NHTSA ID #10003663, MAY 23 2003)

VEHICLE SPEED CONTROL

• TSB #3115 -- HIGH IDLE WHEN CLUTCH IS DEPRESSED. *SC (NHTSA ID #10010198, JANUARY 01 2004)

VEHICLE SPEED CONTROL:CRUISE CONTROL

• TSB #031603 -- OPERATIONAL INFORMATION REGARDING COMPLAINTS OF NO CRUISE CONTROL LIGHT APPEARING ON THE INSTRUMENT PANEL CLUSTER WHEN THE CRUISE CONTROL IS SET. *TT *JB (NHTSA ID #10001888, MARCH 16 2003)

WHEELS

• TSB #060602 -- THIS MESSAGE PERTAINS TO A NEW IMPROVED FLAT WHEEL MOUNT DESIGN ON THE ALUMINUM WHEELS INCORPORATED ON 2003 MODEL YEAR N-CAR VEHICLES. *TT (NHTSA ID #637201, JUNE 06 2002)

SEATS

• TSB #032603 -- BLACK PAINT FLAKES IN THE CARPETING AROUND THE FRONT SEATS. *TT *JB (NHTSA ID #10001871, MARCH 26 2003)

SEATS:FRONT ASSEMBLY:POWER ADJUST

• TSB #01645 -- DRIVER SIDE 6-WAY POWER SEAT INOPERATIVE.*MR (NHTSA ID #10007155, JANUARY 01 2004)

EQUIPMENT

• TSB #052903 -- CLARIFICATION OF SERVICE BULLETIN 02-08-44-012. CERTAIN STEPS IN THE SERVICE BULLETIN TO DISABLE OR ENABLE THE REMOTE KEYLESS ENTRY RADIO PERSONALIZATION FEATURE HAS BEEN DELETED IN THE TECH 2 SOFTWARE. CONCERN WILL BE UPDATED IN JULY REL (NHTSA ID #10003676, MAY 29 2003)
• TSB #09102002 -- A CONDITION COULD EXIST WHERE THE CIGARETTE LIGHTER MAY CAUSE THE FUSE TO BLOW AND THE OUTLET TO BECOME INOP. *TT (NHTSA ID #10009437, SEPTEMBER 10 2002)
• TSB #200602 -- INFORMATION ON INSTALLING THE FRONT LICENSE PLATE COVER. *TT (NHTSA ID #637245, JUNE 20 2002)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #01759 -- XM RAPID ACTIVATION UTILIZATION. *MR (NHTSA ID #10006302, JANUARY 01 2004)
• TSB #01662 -- XM ERROR ON A RADIO DISPLAY. *TT (NHTSA ID #10007248, JANUARY 01 2004)
• TSB #01390 -- XM RADIO MUST BE TUNED TO CHANNEL 1 THROUGH 66 DURING ACTIVATION ATTEMPT. 2004 CHEVROLET CANYON, GMC DENALI, GMC COLORADO ALSO INCLUDED. *TT (NHTSA ID #10004195, NOVEMBER 18 2003)

UNKNOWN OR OTHER

• TSB #000089008E -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10005527, OCTOBER 01 2005)
• TSB #020730022B -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #10004755, OCTOBER 01 2003)
• TSB #000089008B -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10004278, SEPTEMBER 01 2003)
• TSB #020844012A -- ENABLE OR DISABLE REMOTE KEYLESS ENTRY (RKE) RADIO PERSONALIZATION FEATURE. *TT (NHTSA ID #10002841, JUNE 01 2003)
• TSB #01444 -- XM DEALER ASSISTANCE LINE INFORMATION. *TT (NHTSA ID #10004411, JANUARY 01 2003)
• TSB #09202002 -- INCORRECT PAINT CODE. *TT (NHTSA ID #10009477, SEPTEMBER 20 2002)
• TSB #020730022A -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #634931, SEPTEMBER 01 2002)
• TSB #4014 -- PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE. *KB (NHTSA ID #10021074, no date provided)