Print this page

TSB List for the 1998 Ford Ranger

Technical Service Bulletins (TSBs) for the 1998 Ranger are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.

  • STEERING
  • STEERING:HYDRAULIC POWER ASSIST SYSTEM
  • SUSPENSION
  • SUSPENSION:FRONT
  • SUSPENSION:REAR
  • SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
  • SERVICE BRAKES, ELECTRIC
  • SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT
  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
  • SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
  • SERVICE BRAKES, AIR:DISC:ROTOR
  • ENGINE AND ENGINE COOLING:ENGINE
  • ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
  • ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
  • ENGINE AND ENGINE COOLING:COOLING SYSTEM
  • ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
  • FUEL SYSTEM, GASOLINE
  • FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
  • FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
  • FUEL SYSTEM, OTHER
  • POWER TRAIN
  • POWER TRAIN:CLUTCH ASSEMBLY
  • POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
  • POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING
  • POWER TRAIN:MANUAL TRANSMISSION
  • POWER TRAIN:AUTOMATIC TRANSMISSION
  • POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
  • POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
  • POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
  • POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
  • POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
  • POWER TRAIN:DRIVELINE
  • POWER TRAIN:DRIVELINE:DRIVESHAFT
  • POWER TRAIN:AXLE ASSEMBLY
  • POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING
  • POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL
  • ELECTRICAL SYSTEM
  • ELECTRICAL SYSTEM:12V/24V/48V BATTERY
  • ELECTRICAL SYSTEM:WIRING
  • ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
  • ELECTRICAL SYSTEM:IGNITION:SWITCH
  • ELECTRICAL SYSTEM:IGNITION:MODULE
  • ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
  • VISIBILITY:WINDSHIELD
  • VISIBILITY:GLASS, SIDE/REAR
  • VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
  • VISIBILITY:REARVIEW MIRRORS/DEVICES
  • VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
  • VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
  • VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
  • SEAT BELTS
  • STRUCTURE
  • STRUCTURE:FRAME AND MEMBERS
  • STRUCTURE:BODY
  • STRUCTURE:BODY:BUMPERS
  • STRUCTURE:BODY:DOOR
  • VEHICLE SPEED CONTROL
  • VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
  • VEHICLE SPEED CONTROL:LINKAGES
  • VEHICLE SPEED CONTROL:CRUISE CONTROL
  • TIRES
  • WHEELS
  • EQUIPMENT
  • EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
  • EQUIPMENT:OTHER:LABELS
  • EQUIPMENT:APPLIANCE:AIR CONDITIONER
  • UNKNOWN OR OTHER
  • STEERING

    • TSB #17254

      Date Announced:
      OCT 01, 2003
      NHTSA ID:
      #10004908

      CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT Read More »

    • TSB #16040

      Date Announced:
      JUL 01, 2002
      NHTSA ID:
      #636235

      EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT Read More »

    STEERING:HYDRAULIC POWER ASSIST SYSTEM

    • TSB #13440

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610879

      EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT Read More »

    SUSPENSION

    • TSB #15692

      Date Announced:
      MAR 01, 2002
      NHTSA ID:
      #636326

      SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT Read More »

    • TSB #13426

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609691

      EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT Read More »

    • TSB #6727

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608447

      THIS ONLINE AUTOMOTIVE SERVICE BULLETIN CONTAINS PROCEDURES FOR VEHICLES WITH A REAR END SAG. *TT Read More »

    • TSB #13018

      Date Announced:
      JUL 01, 1999
      NHTSA ID:
      #610761

      SOME VEHICLES MAY EXHIBIT A REAR END SAG. *TT Read More »

    • TSB #6326

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #6091671

      SOME VEHICLES MAY EXHIBIT A SAG IN THE REAR END. *TT Read More »

    • TSB #5249

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615366

      INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT Read More »

    • TSB #4634

      Date Announced:
      AUG 01, 1998
      NHTSA ID:
      #615172

      STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT Read More »

    • TSB #9811476

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #613385

      SOME SUPER CAB 4X4 VEHICLES BUILT FROM TWIN CITIES ASSEMBLY PLANTS BETWEEN 08-21-97 AND 03-03-98 MAY EXPERIENCE A NOISE AND / OR VIBRATION CONCERN WHILE DRIVING APPROXIMATELY 35 MPH OR FASTER. Read More »

    • TSB #982537

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #603556

      EXPERIENCING A NOISE AND / OR VIBRATION CONCERN WHILE DRIVING APPROXIMATELY 35MPYH OR FASTER. *YC Read More »

    SUSPENSION:FRONT

    • TSB #042419

      Date Announced:
      DEC 13, 2004
      NHTSA ID:
      #10014096

      REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT Read More »

    • TSB #985045

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613097

      REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT Read More »

    • TSB #985019

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613044

      EXHIBITING A CONDITION OF PULLS TO THE RIGHT. *TT Read More »

    • TSB #98-4732

      Date Announced:
      SEP 01, 1998
      NHTSA ID:
      #607144

      STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS.. Read More »

    SUSPENSION:REAR

    • TSB #15097

      Date Announced:
      JUL 01, 2001
      NHTSA ID:
      #621022

      SUBJECT REGARDING REAR ALIGNMENT OUT OF SPEC CONDITION. *TT Read More »

    • TSB #981616

      Date Announced:
      APR 07, 2000
      NHTSA ID:
      #609753

      LEFT REAR SIDE OF VEHICLE APPEARS LOW. *AK Read More »

    • TSB #99221

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #6089679

      SOME VEHICLES MAY APPEAR TO BE LOW IN THE REAR. *TT Read More »

    • TSB #13207

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090577

      INFORMATION REGARDING REAR END SAG. *MJS Read More »

    • TSB #7026

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090410

      INFORMATION REGARDING REAR END SAG. *MJS Read More »

    • TSB #6285

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #607049

      SOME VEHICLES MAY EXHIBIT CONCERNS WITH A SAG IN THE REAR END. *TT Read More »

    • TSB #12749

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #6091721

      SOME VEHICLES MAY EXHIBIT A SAG IN THE REAR END. *TT Read More »

    SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

    SERVICE BRAKES, ELECTRIC

    • TSB #0076

      Date Announced:
      APR 03, 2000
      NHTSA ID:
      #613573

      INFORMATION REGARDING LOSS OF REGENERATIVE BREAKING AND HIGH BRAKE PEDAL EFFORTS WHILE DRIVING DOWNHILL WITH TRACTION BATTERY AT HIGH STATE OF CHARGE. *MR Read More »

    SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT

    • TSB #02176

      Date Announced:
      SEP 02, 2002
      NHTSA ID:
      #10008580

      LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »

    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

    • TSB #15147

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #624885

      SOME VEHICLES MAY EXHIBIT A BRAKE PEDAL VIBRATION AND/OR STEERING WHEEL MOVEMENT,NOISE,OR BRAKE GRAB/LOCKUP . *ET Read More »

    • TSB #14898

      Date Announced:
      MAY 01, 2001
      NHTSA ID:
      #620215

      SOME VEHCLES MAY EXHIBIT A BRAKE PEDAL VIBRATION AND / OR STEERING WHEEL MOVEMENT DURING LIGHT TO MODERATE BRAKING. *TT Read More »

    • TSB #0076

      Date Announced:
      APR 03, 2000
      NHTSA ID:
      #613573

      INFORMATION REGARDING LOSS OF REGENERATIVE BREAKING AND HIGH BRAKE PEDAL EFFORTS WHILE DRIVING DOWNHILL WITH TRACTION BATTERY AT HIGH STATE OF CHARGE. *MR Read More »

    • TSB #99194

      Date Announced:
      SEP 20, 1999
      NHTSA ID:
      #6090082

      INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »

    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

    • TSB #983572

      Date Announced:
      OCT 13, 1999
      NHTSA ID:
      #607840

      CONCERNS WITH ANTI-LOCK BRAKE SYSTEM (ABS) DIAGNOSTIC TROUBLE CODES AND / OR ABS LIGHT FLASHING WHILE DRIVING. *TT Read More »

    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

    • TSB #985A5

      Date Announced:
      MAR 18, 1998
      NHTSA ID:
      #601003

      HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC Read More »

    • TSB #9814

      Date Announced:
      JAN 19, 1998
      NHTSA ID:
      #605562

      SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT Read More »

    SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

    • TSB #15859

      Date Announced:
      MAY 01, 2002
      NHTSA ID:
      #637710

      SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT Read More »

    • TSB #6035

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #606949

      SOME VEHICLES EQUIPPED WITH TEVES FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT A YELLOW ANTI-LOCK BRAKE LAMP ILLUMINATED WITH NO DIAGNOSTIC TROUBLE CODES IN MEMORY. *TT Read More »

    • TSB #12610

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #605333

      INFORMATION ON REPLACING A FOUR WHEEL ANTI-LOCK BRAKES (4WABS) HYDRAULIC CONTROL UNIT (HUC). *TT Read More »

    • TSB #12230

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615491

      ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »

    • TSB #98B25

      Date Announced:
      AUG 01, 1998
      NHTSA ID:
      #603922

      OWNER NOTIFICATION PROGRAM 98B25-1998 RANGER FOUR-WHEEL ABS INVOICING/WINDOW STICKER CUSTOMER SATISFACTION PROGRAM. Read More »

    SERVICE BRAKES, AIR:DISC:ROTOR

    • TSB #9845

      Date Announced:
      MAR 02, 1998
      NHTSA ID:
      #601264

      AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC Read More »

    ENGINE AND ENGINE COOLING:ENGINE

    • TSB #02221

      Date Announced:
      NOV 11, 2002
      NHTSA ID:
      #10008304

      ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ Read More »

    • TSB #870197

      Date Announced:
      OCT 22, 2002
      NHTSA ID:
      #10000592

      INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »

    • TSB #01124

      Date Announced:
      JUN 25, 2001
      NHTSA ID:
      #622665

      ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT Read More »

    • TSB #9810930

      Date Announced:
      SEP 24, 1999
      NHTSA ID:
      #607488

      SOME VEHICLES MAY EXHIBIT AN ENGINE OIL LEAK FROM THE REAR MAIN CRANKSHAFT SEAL. *TT Read More »

    • TSB #6997

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090310

      SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT Read More »

    • TSB #13180

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090538

      INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS Read More »

    • TSB #5518

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #605190

      INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT Read More »

    ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

    • TSB #01246

      Date Announced:
      DEC 10, 2001
      NHTSA ID:
      #630515

      ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT Read More »

    • TSB #15455

      Date Announced:
      DEC 01, 2001
      NHTSA ID:
      #630562

      SOME VEHICLES EQUIPPED WITH A 2.5/3.0L ENGINE MAY EXHIBIT A SURGE, HESITATION, ROUGH IDLE OR MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES P0171, P0174, P0175. *TT Read More »

    • TSB #01205

      Date Announced:
      OCT 15, 2001
      NHTSA ID:
      #627927

      SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »

    • TSB #01197

      Date Announced:
      OCT 01, 2001
      NHTSA ID:
      #627752

      SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT Read More »

    • TSB #15226

      Date Announced:
      SEP 01, 2001
      NHTSA ID:
      #625775

      SOME VEHICLES EQUIPPED WITH A 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE THAT MAY BE PERCEIVED BY THE CUSTOMER A S ADIESEL TYPE NOISE AND IS KNOWN AS MARBLE NOISE. *TT Read More »

    • TSB #15190

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #625018

      SOME VEHICLES MAY EXHIBIT SURGE, HESITATION, ROUGH IDLE OR MALFUNCTION NDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODES P0171, P0172, NP0174, P0175. *ET Read More »

    • TSB #0147

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619424

      SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT Read More »

    • TSB #00248

      Date Announced:
      NOV 27, 2000
      NHTSA ID:
      #616536

      SOME VEHICLES EQUIPPED WITH A 3.0L ENGINE MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *TT Read More »

    • TSB #14366

      Date Announced:
      SEP 01, 2000
      NHTSA ID:
      #618637

      SOME VEHICLES EQUIPPED WITH 3.0L ENGINE MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *JB Read More »

    • TSB #0073

      Date Announced:
      APR 03, 2000
      NHTSA ID:
      #613568

      SOME VEHICLES EQUIPPED WITH A 3.0L ENGINE MAY EXPERIENCE SPARK KNOCK (PING) UNDER ACCELERATION. **MR Read More »

    • TSB #14076

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613711

      SOME VEHICLES MAY EXHIBIT AN ENGINE SPARK KNOCK (PING) ON ACCELERATION. **MR Read More »

    • TSB #0054

      Date Announced:
      MAR 06, 2000
      NHTSA ID:
      #612948

      VEHICLES MAY EXHIBIT VARIOUS DRIVING CONDITIONS, HARD TO START, ENGINE HESITATION, ROUGH OR UNUSUAL ROLLING IDLE, ENGINE SURGE OR LACK OF POWER, KNOCK, STUMBLE. *MJS Read More »

    • TSB #14366

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #620429

      EXHIBITING SPARK KNOCK (PING) UNDER ACCELERATION. *TT Read More »

    • TSB #13484

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610897

      VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT Read More »

    • TSB #13528

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610914

      SOME VEHICLES WITH 3.0L ENGINES MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *TT Read More »

    • TSB #7471

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610836

      SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT Read More »

    • TSB #7147

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6090765

      EXHIBITING AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT Read More »

    • TSB #99183

      Date Announced:
      SEP 06, 1999
      NHTSA ID:
      #6090051

      SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT Read More »

    • TSB #13283

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6091663

      SOME VEHICLES WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT Read More »

    • TSB #13110

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090508

      INFORMATION REGARDING 4.0L OHV ENGINE-MARBLE TYPE NOISE. *MJS Read More »

    • TSB #13270

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090699

      VEHICLES WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT Read More »

    • TSB #996884

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608880

      CUSTOMERS MAY COMPLAIN OF AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A "DIESEL AND / OR MARBELS IN A TIN CAN RATTLE" ON VEHICLES WITH A 4.OL OVH ENGINE. *TT Read More »

    • TSB #6896

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608921

      SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT Read More »

    • TSB #13110

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091919

      SOME VEHICLES MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBELS IN A TIN CAN RATTLE. *TT Read More »

    • TSB #13118

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091931

      SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT Read More »

    • TSB #13154

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091965

      SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT Read More »

    • TSB #6321

      Date Announced:
      JUN 01, 1999
      NHTSA ID:
      #606801

      SOME VEHICLES MAY EXHIBIT SPARK KNOCK UNDER ACCELERATION. *TT Read More »

    • TSB #99816

      Date Announced:
      MAY 03, 1999
      NHTSA ID:
      #606420

      FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Read More »

    • TSB #6199

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #607018

      VEHICLE MAY EXPERIENCE A DIESEL / MARBEL TYPE NOISE. *TT Read More »

    • TSB #12705

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #6091678

      SOME 4.0L OHV ENGINES MAY EXHIBIT AN INTERNAL LOW ENGINE NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT Read More »

    • TSB #12782

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #607101

      SOME VEHICLES MAY EXHIBIT SPARK KNOCK UNDER ACCELERATION. *TT Read More »

    • TSB #5382

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615455

      SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON, STALL AT TIP-IN FROM IDLE, ENGINE HESITATION, AND / OR SURGE. *TT Read More »

    • TSB #9805009

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613033

      CUSTOMER MAY EXPERIENCE A CRANK AND NO START CONDITION. *TT Read More »

    • TSB #11509

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #613767

      SOME VEHICLES MAY EXHIBIT ERRONEOUS DTCS B1398 AND B1302 WHEN DIAGNOSTIC TEST ARE PERFROMED. *TT Read More »

    • TSB #980216983-20

      Date Announced:
      FEB 16, 1998
      NHTSA ID:
      #600602

      A "BOOMING" NOISE MAY BE HEARD IN THE CAB WHILE DRIVING WITH ENGINE AT 2500-300 RPMS. *YC Read More »

    ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

    • TSB #13844

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612439

      SOME VEHICLES WITH 2.5L ENGINE MAY EXHIBIT A BELT SQUEAL INITIALLY AT COLD START-UP. *TT Read More »

    • TSB #8091

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612288

      SOME VEHICLES EQUIPPED WITH 2.5L ENGINES MAY EXHIBIT A BELT SQUEAL INITIALLY AT COLD START-UP. *TT Read More »

    ENGINE AND ENGINE COOLING:COOLING SYSTEM

    • TSB #99238

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090164

      A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT Read More »

    • TSB #12583

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #605310

      SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A THUMPING NOISE FROM THE COOLING SYSTEM. *TT Read More »

    ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

    • TSB #14583

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617968

      CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB Read More »

    • TSB #14617

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617995

      SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

    • TSB #982010

      Date Announced:
      OCT 12, 1998
      NHTSA ID:
      #603695

      EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC Read More »

    • TSB #98315

      Date Announced:
      MAY 27, 1998
      NHTSA ID:
      #600598

      ON SOME VEHICLES, THE SERVICE BAY DIAGNOSTIC SYSTEM (SBDS) AND/OR NEW GENERATION STAR (NGS) TESTER MAY NOT BE ABLE TO READ THE SIGNAL FROM THE HEATED OXYGEN SENSOR (HO2S). *YC Read More »

    • TSB #9864

      Date Announced:
      MAR 30, 1998
      NHTSA ID:
      #601312

      INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

    • TSB #982310

      Date Announced:
      NOV 23, 1998
      NHTSA ID:
      #603724

      MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Read More »

    FUEL SYSTEM, GASOLINE

    • TSB #996125

      Date Announced:
      JUN 01, 1999
      NHTSA ID:
      #606982

      SUBJECT REGARDING FUEL SYSTEM DIAGNOSTIC. *TT Read More »

    • TSB #976011

      Date Announced:
      NOV 01, 1997
      NHTSA ID:
      #605804

      EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT Read More »

    FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

    • TSB #5230

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615349

      ENGINEERING IS INTERESTED IN LOCATING CERTAIN SUPER CAB VEHICLES WITH 126 INCH WHEEL BASE AND 19.5 GALLON FUEL TANK FOR SERVICE REQUIRING FUEL TANK REPLACEMENT. *TT Read More »

    • TSB #12179

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613235

      INFORMATION REGARDING ENGINEERING THAT IS INTERESTED IN LOCATING ANY 1998 RANGER 126 INCH W/B SUPER CAB WITYH 19.5 GALLON FUEL TANK FOR SERVICE REQUIRING FUEL TANK REPLACEMENT, PRODUCTION DATES MUST BE BETWEEN 5/19/98 AND 7/31/98. Read More »

    FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

    • TSB #12264

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615517

      SOME VEHICLES MAY EXHIBIT A CRANK NO START CONCER, OR THE DIAGNOSTICS HAVE VERIFIED THAT THE FUEL PUMP IS INOPERATIVE. *TT Read More »

    • TSB #5347

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615430

      SOME VEHICLES MAY EXHIBIT A CRANK NO START CONCERN, OR THE DIAGNOSTICS HAVE VERIFIED THAT THE FUEL PUMP IS INOPERATIVE. *TT Read More »

    • TSB #9818

      Date Announced:
      JAN 19, 1998
      NHTSA ID:
      #605568

      FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT Read More »

    FUEL SYSTEM, OTHER

    • TSB #0398

      Date Announced:
      MAY 12, 2003
      NHTSA ID:
      #10002780

      MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT Read More »

    POWER TRAIN

    • TSB #0332

      Date Announced:
      FEB 17, 2003
      NHTSA ID:
      #10002479

      THUMP TYPE NOISE/VIBRATION HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT Read More »

    • TSB #15887

      Date Announced:
      MAY 01, 2002
      NHTSA ID:
      #637755

      SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). Read More »

    • TSB #0282

      Date Announced:
      APR 29, 2002
      NHTSA ID:
      #637922

      SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. Read More »

    • TSB #0036

      Date Announced:
      FEB 07, 2000
      NHTSA ID:
      #612387

      VEHICLES MAY EXPERIENCE BUZZING AND OR GRINDING NOISE DURING 2-3 SHIFT- VEHICLES EQUIPPED WITH M50D TRANSMISSION AND BUILT BEFORE 11/1/99. *MJS Read More »

    • TSB #13794

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612815

      VEHICLES EQUIPPED WITH M5OD R1 TRANSMISSIONS MAT EXHIBIT A 2-3 UPSHIFT GRIND. *MJS Read More »

    • TSB #7885

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612270

      THE VEHICLE MAY EXHIBIT THE SPEEDOMETER/ODOMETER INOPERATIVE AS WELL AS MALFUNCTION INDICATOR LAMPS ILLUMINATED OR FLASHING AFTER THE GENERIC ELECTRONIC MODULE (GEM), CENTRAL TIMER MODULE (CTM), OR FOR WHEEL ANTI-LOCK BRAKE SYSTEM (4WABS) ... Read More »

    • TSB #13745

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612742

      SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS Read More »

    • TSB #991813

      Date Announced:
      SEP 06, 1999
      NHTSA ID:
      #6090076

      EXPERIENCING AN INOPERATIVE OR INACCURATE ODOMETER / SPEEDOMETER READINGS. *TT Read More »

    • TSB #9943

      Date Announced:
      MAR 08, 1999
      NHTSA ID:
      #604751

      INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »

    • TSB #12102

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613088

      SOME MANUAL TRANSMISSIONS MAY EXHIBIT A CONCERN OF ENGINE IDLE HIGH DURING DECELERATION. *MJS Read More »

    • TSB #12152

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613171

      SOME VEHICLES WITH 4 X 4 OPTION OPERATING IN 4 X 2 MODE MAY EXHIBIT A PING SOUND ON SLIGHT TO MODERATE ACCELERATION IN FORWARD OR REVERSE. *MJS Read More »

    • TSB #12153

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613172

      SOME 3.0L AND 4.0L RANGERS WITH 4 X 4 OPERATING IN 4.2 MODE MAY EXHIBIT A SLIGHT OR A ROLLING THUMP/BUMP ON SLIGHT TO MODERATE ACCELERATION. *MJS Read More »

    POWER TRAIN:CLUTCH ASSEMBLY

    • TSB #0057

      Date Announced:
      MAR 06, 2000
      NHTSA ID:
      #612953

      SOME VEHICLES MAY EXPERIENCE A SQUAWKING/EEKING NOISE THAT MAY BE HEARD FROM THE CLUTCH ON ACCELERATION FROM A STOP OR WHEN UNDER LOAD IN FIRST GEAR. *MJS Read More »

    • TSB #13442

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610880

      VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT Read More »

    • TSB #13289

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609610

      OWNERS OF VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT Read More »

    • TSB #7119

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6090714

      SOME VEHICLES EQUIPPED WITH 2.5L MANUAL TRANSMISSIONS MAY EXHIBIT A HIGH ENGINE IDLE CONDITION ON DECELERATION OR WHEN DISENGAGING THE CLUTCH. *TT Read More »

    • TSB #7206

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6090799

      VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT Read More »

    • TSB #6991

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090299

      VEHICLES EQUIPPED WITH 4.0L OHV AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT Read More »

    • TSB #13175

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090528

      INFORMATION REGARDING CLUTCH SQUAWK NOISE ON TAKE OFF. *MJS Read More »

    • TSB #982521

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #603546

      INFORMATION ON THE PARTS CATALOG BOOK REFERENCES AN INCORRECT CLUTCH PART NUMBER FOR SOME VEHICLES WITH THE 3.0L ENGINE. *YC Read More »

    POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

    • TSB #0255

      Date Announced:
      MAR 18, 2002
      NHTSA ID:
      #636047

      HOOTING, EEKING OR MOANING NOISE COMING FROM THE CLUTCH WHEN SHIFTING GEARS. *TT Read More »

    • TSB #9811479

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #613388

      THE PARTS CATALOG BOOK REFERENCES AN INCORRECT CLUTCH PART NUMBER FOR CERTAIN VEHICLES WITH THE 3.0L ENGINE. *TT Read More »

    POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING

    • TSB #8560

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613676

      SOME VEHICLES MAY EXHIBIT AN OIL LEAK AT THE REAR SEAL OF THE TRANSMISSION EXTENSION HOUSING. **MR Read More »

    • TSB #14072

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613719

      SOME VEHICLES MAY EXHIBIT AN OIL LEAK AT THE REAR SEAL OF THE TRANSMISSION EXTENSION HOUSING. *TT Read More »

    POWER TRAIN:MANUAL TRANSMISSION

    • TSB #02138

      Date Announced:
      NOV 10, 2003
      NHTSA ID:
      #635998

      LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. Read More »

    • TSB #13835

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612428

      SOME 3.0L MANUAL TRANSMISSION EQUIPPED VEHICLES MAY EXHIBIT A CONCERN OF ENGINE IDLE HIGH (1500-2000 RPM) DURING DECELERATION. *TT Read More »

    • TSB #7366

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610793

      SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). Read More »

    • TSB #13423

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609688

      VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL AND CLUTCH ENGAGED. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION

    • TSB #0015

      Date Announced:
      JAN 10, 2000
      NHTSA ID:
      #612203

      INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »

    • TSB #8008

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612506

      BUZZING AND GRINDING NOTCHY NOISE WHEN SHIFTING(2-3 UPSHIFT). Read More »

    • TSB #7353

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610785

      SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »

    • TSB #13412

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609668

      SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT Read More »

    • TSB #99152

      Date Announced:
      JUL 26, 1999
      NHTSA ID:
      #608431

      INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Read More »

    • TSB #9986

      Date Announced:
      MAY 03, 1999
      NHTSA ID:
      #606406

      SOME VEHICLES MAY EXHIBIT AN OVERDRIVE (O/D) LIGHT FLASHING WITH DIAGNOSTIC TROUBLE CODE (DTC) P0741 AND / OR P1740. *TT Read More »

    • TSB #9946

      Date Announced:
      MAR 08, 1999
      NHTSA ID:
      #604762

      CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT Read More »

    • TSB #982312

      Date Announced:
      NOV 23, 1998
      NHTSA ID:
      #603740

      ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC Read More »

    • TSB #985174

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613304

      SOME VEHICLES WITH 4X4 OPTION IN 4X2 MODE MAY EXHIBIT A PING SOUND ON SLIGHT TO MODERATE ACCELERATION IN FORWARD OR REVERSE. *TT Read More »

    • TSB #985175

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613305

      SOME VEHICLES WITH 4X4 OPTION OPERATING IN 4X2 MAY EXHIBIT A SLIGHT OR A ROLLING THUMP / BUMP ON SLIGHT TO MODERATE ACCELERATION. *TT Read More »

    • TSB #9888

      Date Announced:
      APR 27, 1998
      NHTSA ID:
      #601238

      INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

    • TSB #042107

      Date Announced:
      DEC 13, 2004
      NHTSA ID:
      #10014086

      GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »

    • TSB #04217

      Date Announced:
      NOV 01, 2004
      NHTSA ID:
      #10013369

      GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

    • TSB #13505

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #614630

      ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

    • TSB #03148

      Date Announced:
      JUL 21, 2003
      NHTSA ID:
      #10003748

      NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »

    • TSB #002310

      Date Announced:
      NOV 13, 2000
      NHTSA ID:
      #616522

      SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »

    • TSB #981613

      Date Announced:
      APR 07, 2000
      NHTSA ID:
      #609748

      TRANSMISSION FLUID LEAKS AT RADIATOR. YD Read More »

    • TSB #9946

      Date Announced:
      JAN 01, 1999
      NHTSA ID:
      #606733

      CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

    POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

    • TSB #98813

      Date Announced:
      APR 27, 1998
      NHTSA ID:
      #601244

      SOME VEHICLES MAY EXHIBIT INTERMITTENT OR NO 4X4 ENGAGEMENT , EVEN WHILE THE 4X4 ILLUMINATED, AND/OR A CLUNKING NOISE HEARD WHILE SHIFTING INTO 4X4 ON THE FLY. *YC Read More »

    POWER TRAIN:DRIVELINE

    • TSB #99161

      Date Announced:
      AUG 09, 1999
      NHTSA ID:
      #607653

      EXPERIENCING AN AUDIBLE PINGING OR CREAKING (NOT A CLUNKING NOISE) HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE SUCH AS WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE. Read More »

    • TSB #6603

      Date Announced:
      JUL 01, 1999
      NHTSA ID:
      #610704

      SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT Read More »

    • TSB #98514

      Date Announced:
      MAR 16, 1998
      NHTSA ID:
      #601303

      CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT Read More »

    POWER TRAIN:DRIVELINE:DRIVESHAFT

    • TSB #04237

      Date Announced:
      NOV 29, 2004
      NHTSA ID:
      #10013414

      DRIVESHAFT THUMP CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP. *EH Read More »

    • TSB #030302

      Date Announced:
      FEB 01, 2003
      NHTSA ID:
      #10002516

      DRIVESHAFT - THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT Read More »

    • TSB #03048

      Date Announced:
      JAN 05, 2003
      NHTSA ID:
      #10008280

      THUMP/CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP ON CERTAIN 4X4 SUPER CAB EQUIPPED WITH AUTOMATIC TRANSMISSION AND STEEL DRIVESHAFT. *TT Read More »

    • TSB #02192

      Date Announced:
      SEP 30, 2002
      NHTSA ID:
      #10008587

      DRIVESHAFT-THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. Read More »

    • TSB #011111

      Date Announced:
      JUN 11, 2001
      NHTSA ID:
      #622656

      SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY DRIVESHAFT THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. Read More »

    • TSB #0196

      Date Announced:
      MAY 14, 2001
      NHTSA ID:
      #620159

      SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. *TT Read More »

    • TSB #7886

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612273

      THE VEHICLE EQUIPPED WITH A3.0L AND AUTOMATIC/MANUAL TRANSMISSION MAY VIBRATE AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEALS TO LEAK OR THE TRANSMISSION EXTENSION HOUSING ABUISHING TO SPIN. Read More »

    POWER TRAIN:AXLE ASSEMBLY

    • TSB #030508

      Date Announced:
      APR 01, 2005
      NHTSA ID:
      #10017891

      FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT Read More »

    • TSB #0358

      Date Announced:
      MAR 17, 2003
      NHTSA ID:
      #10001922

      FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB Read More »

    • TSB #0242

      Date Announced:
      MAR 04, 2002
      NHTSA ID:
      #636056

      CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT Read More »

    • TSB #0186

      Date Announced:
      APR 30, 2001
      NHTSA ID:
      #619276

      ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT Read More »

    • TSB #14847

      Date Announced:
      APR 01, 2001
      NHTSA ID:
      #619330

      CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT Read More »

    • TSB #8377

      Date Announced:
      MAR 01, 2000
      NHTSA ID:
      #612775

      EXPERIENCE A GROWLING NOISE FROM THE FRONT AXLE IN 4X2 OR 4X4 MODE AFTER ENGAGING 4X4 MODE AND THEN DISENGAGING WITHIN 40 SECONDS. *TT Read More »

    • TSB #6408

      Date Announced:
      JUN 01, 1999
      NHTSA ID:
      #606833

      SOME VEHICLES WITH 4X4 OPTION WHILE OPERATING IN 4X2 MODE MAY EXHIBIT A LIGHT OR A ROLLING THUMP / BUMP SENSATION ON SLIGHT TO MODERATE ACCELERATION AND DECELERATION. *TT Read More »

    • TSB #12843

      Date Announced:
      JUN 01, 1999
      NHTSA ID:
      #606905

      SOME 4X4 VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT Read More »

    • TSB #12905

      Date Announced:
      JUN 01, 1999
      NHTSA ID:
      #606937

      SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT Read More »

    • TSB #6032

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #6091736

      SOME VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT Read More »

    • TSB #12521

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #6091767

      VEHICLES WITH LIMITED SLIP / TRACTION-LOK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING. *TT Read More »

    • TSB #983074

      Date Announced:
      FEB 27, 1998
      NHTSA ID:
      #607369

      CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT Read More »

    POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING

    • TSB #00242

      Date Announced:
      NOV 27, 2000
      NHTSA ID:
      #616530

      ON SOME VEHICLES THERE MAY BE A VIBRATION AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEAL TO LEAK OR THE TRANSMISSION EXTENSION HOUSING BUSHING TO MOVE OUT OF POSITION OR BECOME DAMAGED. Read More »

    • TSB #00151

      Date Announced:
      JUL 24, 2000
      NHTSA ID:
      #618574

      VEHICLES MAY EXPERIENCE VIBRATION FELT AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEAL TO LEAK OR THE TRANSMISSION EXTENSION HOUSING BLUSHING TO MOVE OUT OF POSITION OR BECOME DAMAGED ON SOME VEHICLES. Read More »

    • TSB #13543

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610921

      SOME VEHICLES EQUIPPED WITH 3.0L ENGINE AND AUTOMATIC / MANUAL TRANSMISSION MAY EXHIBIT TRANSMISSION FLUID LEAKAGE FROM THE TRANSMISSION EXTENSION HOUSING. *TT Read More »

    POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

    • TSB #8512

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613657

      SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR Read More »

    • TSB #14056

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613704

      SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR Read More »

    ELECTRICAL SYSTEM

    • TSB #03203

      Date Announced:
      OCT 13, 2003
      NHTSA ID:
      #10004886

      MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »

    • TSB #03181

      Date Announced:
      SEP 15, 2003
      NHTSA ID:
      #10004027

      REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »

    • TSB #01109

      Date Announced:
      MAY 28, 2001
      NHTSA ID:
      #620165

      SOME ELECTRIC VEHICLE (EV) RANGERS MAY EXHIBIT A NO-CHARGE CONDITION. THERE ARE SEVERAL POSSIBLE CAUSES WHY THE BATTERY CONTROL MODULE (BCM) MIGHT NOT ALLOW CHARGING (AS INDICATED BY THE OP_STATES). Read More »

    • TSB #00225

      Date Announced:
      OCT 30, 2000
      NHTSA ID:
      #618562

      SOME ELECTRIC VEHICLES MAY EXHIBIT A LOW SPEED SHUDDER ON LIGHT ACCELERATION. *JB Read More »

    • TSB #99B17

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6089633

      OWNER NOTIFICATION PROGRAM REGARDING RANGER ELECTRIC-VEHICLE COMPONENT UPGRADES. *TT Read More »

    • TSB #98246

      Date Announced:
      DEC 07, 1998
      NHTSA ID:
      #604059

      FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »

    • TSB #982453

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #603525

      SOME VEHICLES MAY EXHIBIT ERRONEOUS DTCS B1398 & B1302 WHEN DIAG. *YC Read More »

    ELECTRICAL SYSTEM:12V/24V/48V BATTERY

    • TSB #0245

      Date Announced:
      MAR 04, 2002
      NHTSA ID:
      #636065

      INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT Read More »

    • TSB #99M05

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #6090038

      SOME VEHICLES MAY EXPERIENCE PREMATURE TRACTION BATTERY WEAR-OUT. FORD IS PROVIDING FULL BATTERY COVERAGE. *TT Read More »

    • TSB #99167

      Date Announced:
      AUG 09, 1999
      NHTSA ID:
      #607661

      INFORMATION ON POSSIBLE BATTERY OVERCHARGE WHILE USING NGS TESTER. *TT Read More »

    • TSB #99163

      Date Announced:
      AUG 09, 1999
      NHTSA ID:
      #607671

      THIS BULLETIN MENTIONS CLARIFICATION ON HOW TO OBTAIN RANGER ELECTRIC VEHICLE (EV) TRACTION BATTERY MODULES. *TT Read More »

    • TSB #99164

      Date Announced:
      AUG 09, 1999
      NHTSA ID:
      #607672

      INFORMATION ON JUMP START PROCEDURES FOR RANGER ELECTRIC VEHICLE (EV) AUXILIARY BATTERY. *TT Read More »

    ELECTRICAL SYSTEM:WIRING

    • TSB #99222

      Date Announced:
      OCT 18, 1999
      NHTSA ID:
      #6089681

      SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »

    ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

    • TSB #982526

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #603550

      SOME VEHICLES MAY EXPERIENCE VARIOUS CONCERNS SUCH AS INTERMITTENT WINDSHIELD WIPER OPERATION WITHOUT COMMAND, DOME LIGHTS REMAINING ON, AND/OR THE DOOR CHIMES REMAING ON. *YC Read More »

    ELECTRICAL SYSTEM:IGNITION:SWITCH

    • TSB #012113

      Date Announced:
      OCT 29, 2001
      NHTSA ID:
      #627774

      SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »

    ELECTRICAL SYSTEM:IGNITION:MODULE

    • TSB #01193

      Date Announced:
      OCT 01, 2001
      NHTSA ID:
      #627683

      ON SOME ELECTRIC AND ELECTRIC POSTAL VEHICLES, DIAGNOSTIC TROUBLE CODE B2785 TRACTION INVERTER MODULE (TIM) MAY BE SET AND THE VEHICLE WILL ENTER A POWER LIMITED MODE OF OPERATION. *TT Read More »

    • TSB #9943

      Date Announced:
      MAR 08, 1999
      NHTSA ID:
      #604751

      INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »

    • TSB #5705

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #605194

      VEHICLE EXHIBITING MULTIPLE GENERIC ELECTRONIC MODULE (GEM) RELATED SYMPTOMS. *TT Read More »

    ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

    • TSB #12154

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613173

      SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS Read More »

    VISIBILITY:WINDSHIELD

    • TSB #13244

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090641

      INFORMATION REGARDING WINDNOISE FROM WINDSHIELD/COWL AREA. *MJS Read More »

    • TSB #13054

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091846

      EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT Read More »

    VISIBILITY:GLASS, SIDE/REAR

    • TSB #9839

      Date Announced:
      FEB 16, 1998
      NHTSA ID:
      #600592

      THE DRIVER'S AND/OR PASSENGER DOOR GLASS MAY Read More »

    VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

    • TSB #0146

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619423

      SOME VEHICLES MAY EXHIBIT A CHATTER OR BINDING CONDITION WHEN OPERATING THE POWER SIDE WINDOWS EITHER IN THE DOWN OR UP MODE. *TT Read More »

    • TSB #996780

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608469

      THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT Read More »

    • TSB #985085

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613213

      SOME VEHICLES WITH POWER WINDOWS MAY EXHIBIT WINDOW CHATTERING OR JERKING MOTION WHEN OPERATING IN THE DOWN MODE. *AK *TT Read More »

    • TSB #98158

      Date Announced:
      AUG 03, 1998
      NHTSA ID:
      #609558

      THE DRIVER'S AND PASSENGER'S DOOR GLASS CHATTER WHEN OPERATING THE WINDOW IN DOWN MODE. Read More »

    • TSB #9811488

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #613399

      SOME VEHICLES EQUIPPED WITH A CTM (CENTRAL TIMER MODULE) MAY EXPERIENCE INTERMITTENT WIPER OPERATION WITHOUT COMMAND; DOME LIGHTS REMAINING ON; OR THE DOOR CHIMES REMAINING ON. *TT Read More »

    • TSB #98121

      Date Announced:
      JAN 19, 1998
      NHTSA ID:
      #605595

      SUBJECT REGARDING POWER WINDOW TRAVELLING 25 - 127 MM (1-5 INCHES) DOWNWARD WHEN USING ONE-TOUCHDOWN MODE. *TT Read More »

    • TSB #976011

      Date Announced:
      NOV 01, 1997
      NHTSA ID:
      #605805

      TECHNICIANS EXPERIENCING YELLOW POP-UPS ON SERVICE BAY DIAGNOSTIC SYSTEM (SBDS)." *TT Read More »

    VISIBILITY:REARVIEW MIRRORS/DEVICES

    • TSB #983071

      Date Announced:
      FEB 01, 1998
      NHTSA ID:
      #607365

      BRIEF INFORMATION REGARDING THE IMPROVED SAIL MOUNT MANUAL MIRROR. *TT Read More »

    VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

    • TSB #9867

      Date Announced:
      MAR 30, 1998
      NHTSA ID:
      #601318

      INFORMATION ON THE REVISED MANUAL OUTSIDE REARVIEW MIRRORS BUILT THROUGH 2/13/98. *TT Read More »

    VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

    • TSB #01156

      Date Announced:
      AUG 06, 2001
      NHTSA ID:
      #623944

      SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »

    VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

    • TSB #11512

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #613774

      ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT Read More »

    SEAT BELTS

    • TSB #982730

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #603588

      EXHIBITING A BROKEN SEAT BACK HANDLE LEVER. *YC Read More »

    STRUCTURE

    • TSB #98203

      Date Announced:
      JAN 01, 1999
      NHTSA ID:
      #604389

      CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT Read More »

    • TSB #9811338

      Date Announced:
      FEB 01, 1998
      NHTSA ID:
      #607507

      SOME VEHICLES MY BE MISSING FENDER HOLES TO MOUNT MUD FLAPS. *TT Read More »

    STRUCTURE:FRAME AND MEMBERS

    • TSB #98155

      Date Announced:
      AUG 03, 1998
      NHTSA ID:
      #609535

      SQUEAKING AND CREAKING NOISE COMING FROM CAB WHILE DRIVING. YD Read More »

    STRUCTURE:BODY

    • TSB #7126

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6090720

      SOME VEHICLES MAY EXHIBIT WINDNOISE HEARD FROM THE COWL / WINDSHIELD AREA. *TT Read More »

    • TSB #983140

      Date Announced:
      SEP 22, 1999
      NHTSA ID:
      #607413

      EXPERIENCING A SQUEAKING / CREEKING SOUND INSIDE THE PASSENGER COMPARTMENT WHEN THE VEHICLE IS MOVING. *TT Read More »

    • TSB #98203

      Date Announced:
      JAN 01, 1999
      NHTSA ID:
      #604389

      CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT Read More »

    • TSB #982323

      Date Announced:
      NOV 23, 1998
      NHTSA ID:
      #603930

      INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC Read More »

    • TSB #98203

      Date Announced:
      OCT 12, 1998
      NHTSA ID:
      #603688

      CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC Read More »

    • TSB #98512

      Date Announced:
      MAR 16, 1998
      NHTSA ID:
      #601301

      EXPERIENCING A SQUEAKING / RATTLING NOISE HEAR FROM THE VEHICLE WHILE THE VEHICLE IS MOVING. *YC Read More »

    • TSB #9844

      Date Announced:
      MAR 02, 1998
      NHTSA ID:
      #601263

      SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC Read More »

    • TSB #9831

      Date Announced:
      FEB 16, 1998
      NHTSA ID:
      #600585

      REPAIRS TO VINYL COVERED SURFACES. *YC Read More »

    • TSB #9833

      Date Announced:
      FEB 16, 1998
      NHTSA ID:
      #600587

      SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC Read More »

    • TSB #9811303

      Date Announced:
      FEB 01, 1998
      NHTSA ID:
      #607495

      SOME VEHICLES MAY EXPERIENCE A SQUEEK / CREEK SOUND WITHIN THE CAB OF THE TRUCK WHILE DRIVING. *TT Read More »

    STRUCTURE:BODY:BUMPERS

    • TSB #02232

      Date Announced:
      NOV 25, 2002
      NHTSA ID:
      #10008311

      FRAME MOUNTED FRONT BUMPER BRACKETS SERVICE KIT. *TT Read More »

    STRUCTURE:BODY:DOOR

    • TSB #99242

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090184

      INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT Read More »

    • TSB #6468

      Date Announced:
      JUN 01, 1999
      NHTSA ID:
      #606862

      EXPERIENCING A SQUEAK SOUND WHILE OPENING OR CLOSING THE FRONT OR REAR DOOR(S). *TT Read More »

    • TSB #12873

      Date Announced:
      JUN 01, 1999
      NHTSA ID:
      #6092037

      SOME VEHICLES MAY EXHIBIT A SQUEAK SOUND WHILE OPENING OR CLOSING THE FRONT OR REAR (4DR) DOOR(S). *TT Read More »

    • TSB #99-8-15

      Date Announced:
      MAY 03, 1999
      NHTSA ID:
      #606419

      SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT Read More »

    • TSB #982516

      Date Announced:
      DEC 21, 1998
      NHTSA ID:
      #603654

      LIFT EFFORT IS EXCESSIVE ON THE DRIVER AND / OR PASSENGER OUTSIDE DOOR HANDLE. *YC Read More »

    • TSB #12246

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615503

      SOME VEHICLES BUILT PRIOR TO 11/15/98 MAY REQUIRE EXCESSIVE EFFORT TO LIFT THE OUTSIDE (R/L) DOOR HANDLE. *TT Read More »

    • TSB #5317

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615417

      EXPERIENCING EXCESSIVE EFFORT TO LIFT THE OUTSIDE (L/R) DOOR HANDLE ON VEHICLES BUILT PRIOR TO 11/15/1998. *TT Read More »

    • TSB #98163

      Date Announced:
      AUG 17, 1998
      NHTSA ID:
      #6090873

      LOCKS FAILED. YD Read More »

    VEHICLE SPEED CONTROL

    • TSB #13795

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612816

      SOME VEHICLES WITH 2.5L MANUAL TRANSMISSION MAY EXHIBIT A HIGH IDLE CONDITION ON DECELERATION AND/OR WHEN THE CLUTCH IS DISENGAGED. *MJS Read More »

    • TSB #13241

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090636

      INFORMATION REGARDING SLOW RETURN TO IDLE. *MJS Read More »

    • TSB #99134

      Date Announced:
      JUN 28, 1999
      NHTSA ID:
      #606496

      EXPERIENCING A THUMP AND / OR BUMP SENSATION ON LIGHT ACCELERATION AND / OR DECELERATION ON SOME VEHICLES. *TT Read More »

    • TSB #12827

      Date Announced:
      JUN 01, 1999
      NHTSA ID:
      #606900

      CONCERNS WITH THUMP / BUMP SENSATION ON ACCELERATION. *TT Read More »

    • TSB #985161

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613295

      SOME 3.0L MANUAL TRANSMISSION EQUIPPED VEHICLES MAY EXHIBIT A CONCERN OF ENGINE IDLE HIGH (1500 - 2000 RPM) DURING DECELERATION. *TT Read More »

    VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

    • TSB #98513

      Date Announced:
      MAR 16, 1998
      NHTSA ID:
      #601302

      A VIBRATION OR BIZZING MAY BE FELT THROUGH THE THROTTLE PEDAL ON SOME VEHICLES. *TT Read More »

    • TSB #9811348

      Date Announced:
      FEB 01, 1998
      NHTSA ID:
      #607517

      SOME VEHICLES EXHIBITING A THROTTLE PEDAL BUZZING. *TT Read More »

    VEHICLE SPEED CONTROL:LINKAGES

    • TSB #99S09

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #606320

      RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT Read More »

    VEHICLE SPEED CONTROL:CRUISE CONTROL

    • TSB #14547

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617919

      SOME VEHICLES MAY EXHIBIT SURGE, HESITATION OR ROUGH IDLE OR MALFUNCTION INDICATOR LAMP ON W/ DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, AND P0175. *JB Read More »

    • TSB #0035

      Date Announced:
      FEB 07, 2000
      NHTSA ID:
      #612323

      VEHICLES MAY EXPERIENCE HIGH IDLE. *MJS Read More »

    • TSB #8007

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612502

      A HIGH IDLE CONDITION ON DECELERATION AND/OR WHEN THE CLUTCH IS DISENGAGED. Read More »

    • TSB #6574

      Date Announced:
      JUL 01, 1999
      NHTSA ID:
      #610692

      SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT Read More »

    TIRES

    • TSB #01B77

      Date Announced:
      OCT 01, 2001
      NHTSA ID:
      #628153

      OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT Read More »

    • TSB #995157

      Date Announced:
      MAY 01, 1999
      NHTSA ID:
      #606945

      INFORMATION ON MAINTAINING TIRE PRESSURE. *TT Read More »

    • TSB #12554

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #605291

      SUBJECT REGARDING REVOLUTIONS PER MILE TIRE SIZE DATA. *TT Read More »

    • TSB #9852

      Date Announced:
      APR 13, 1998
      NHTSA ID:
      #601290

      INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC Read More »

    WHEELS

    • TSB #11811

      Date Announced:
      AUG 01, 1998
      NHTSA ID:
      #615308

      SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT Read More »

    • TSB #4703

      Date Announced:
      AUG 01, 1998
      NHTSA ID:
      #615243

      SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT Read More »

    • TSB #9811469

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #613381

      SOME VEHICLES MAY RECEIVE INCORRECT MUD FLAPS DURING INSTALLATION AND WILL NOT FIT PROPERLY TO THE VEHICLE. *TT Read More »

    • TSB #982530

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #603552

      SOME VEHICLES MAY RECEIVE INCORRECT MUD FLAPS DURING INSTALLATION AND WILL NOT FIT PROPERLY TO THE VEHICLE. *YC Read More »

    • TSB #9866

      Date Announced:
      MAR 30, 1998
      NHTSA ID:
      #601317

      IT MAY BE DIFFICULT TO INSTALL MUD FLAPS ONTO SOME VEHICLES. *YC Read More »

    EQUIPMENT

    • TSB #15095

      Date Announced:
      JUL 01, 2001
      NHTSA ID:
      #621020

      INFORMATION PERTAINING TO FUEL OCTAINE PARAMETER ADJUSTMENT WITH NGS. *TT Read More »

    • TSB #01118

      Date Announced:
      JUN 11, 2001
      NHTSA ID:
      #622650

      SUBJECT REGARDING NEW VERSION 3.0 DIAGNOSTIC SOPTWARE AVAILABLE FOR CERTAIN E.V. VEHICLES. *TT Read More »

    • TSB #01412

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619428

      HIGH VOLTAGE INSULATED SAFETY GLOVES TESTING AND ORDERING INFORMATION. *TT Read More »

    • TSB #8164

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612338

      INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT Read More »

    • TSB #5134

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615330

      SOME SUPERCABS MAY EXHIBIT A BUZZ FROM THE REAR SPEAKERS. THIS MAY BE THE INTERIOR TRIM VIBRATING AT TIMES. *TT Read More »

    EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

    • TSB #99129

      Date Announced:
      JUN 14, 1999
      NHTSA ID:
      #606460

      EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »

    • TSB #5652

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #605192

      COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT Read More »

    • TSB #12518

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #6091761

      CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT Read More »

    • TSB #12573

      Date Announced:
      MAR 01, 1999
      NHTSA ID:
      #605297

      INFORMATION REGARDING THE AUDIO SYSTEM SELECTIVE LIGHTING FEATURE. *TT Read More »

    • TSB #5133

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615329

      SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM / FM CASS / CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *TT Read More »

    • TSB #12127

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613149

      SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *MJS Read More »

    • TSB #12128

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613150

      SOME RANGER SUPERCABS MAY EXHIBIT A BUZZ FROM THE REAR SPEAKERS. *MJS Read More »

    • TSB #985133

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613270

      SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *TT Read More »

    • TSB #985134

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613271

      SOME SUPERCABS MAY EXHIBIT A BUZZ FROM THE REAR SPEAKERS. *TT Read More »

    • TSB #982671

      Date Announced:
      APR 01, 1998
      NHTSA ID:
      #603569

      SOME VEHICLES MAY EXPERIENCE POOR RADIO RECEPTION ( AM/FM). *YC Read More »

    EQUIPMENT:OTHER:LABELS

    • TSB #98L22

      Date Announced:
      OCT 01, 1998
      NHTSA ID:
      #604920

      SUBJECT ON REVISED SAFETY CERTIFICATION LABELS. *TT Read More »

    EQUIPMENT:APPLIANCE:AIR CONDITIONER

    • TSB #01212

      Date Announced:
      OCT 29, 2001
      NHTSA ID:
      #627756

      SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A LOUD A/C CLUTCH ENGAGEMENT. *TT Read More »

    • TSB #01186

      Date Announced:
      SEP 17, 2001
      NHTSA ID:
      #625700

      INFORMATION ON CLIMATE CONTROL, LOUD A/C CLUTCH CYCLING NOISE.*JB Read More »

    • TSB #15227

      Date Announced:
      SEP 01, 2001
      NHTSA ID:
      #625777

      SOME EV VEHICLES MAY EXHIBIT A/C INOPEATIVE OR DIAGNOSTIC TROUBLE CODES RELATED TO A/C SYSTEM. *TT Read More »

    • TSB #15198

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #624982

      SOME VEHICLES MAY EXHIBIT LOUD A/C CLUTCH CYCLING NOISE CONDITION. *JG Read More »

    • TSB #15167

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #624656

      SOME VEHICLES MAY EXHIBIT A LOUD COMPRESSOR CYCLING NOISE. *YH Read More »

    • TSB #98165

      Date Announced:
      APR 07, 2000
      NHTSA ID:
      #609751

      EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD Read More »

    • TSB #99196

      Date Announced:
      SEP 20, 1999
      NHTSA ID:
      #6090087

      INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »

    • TSB #6692

      Date Announced:
      JUL 01, 1999
      NHTSA ID:
      #610733

      SOME VEHICLES MAY EXHIBIT NO / LOW AIR CONDITIONER PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE. *TT Read More »

    • TSB #12997

      Date Announced:
      JUL 01, 1999
      NHTSA ID:
      #614782

      SOME VEHICLES MAY EXHIBIT NO / LOW A/C PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE. *TT Read More »

    • TSB #98238

      Date Announced:
      NOV 23, 1998
      NHTSA ID:
      #603722

      CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC Read More »

    • TSB #12138

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613159

      VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *MJS Read More »

    • TSB #985178

      Date Announced:
      NOV 01, 1998
      NHTSA ID:
      #613308

      SOME VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *TT Read More »

    • TSB #982013

      Date Announced:
      OCT 12, 1998
      NHTSA ID:
      #603698

      SOME VEHICLES MAY EXHIBIT REDUCED A/C AIR FLOW, REDUCED DRIVING RANGE, AND/ OR REDUCED A/C PERFORMANCE. *YC Read More »

    UNKNOWN OR OTHER

    • TSB #15605

      Date Announced:
      FEB 01, 2002
      NHTSA ID:
      #630653

      SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »

    • TSB #15504

      Date Announced:
      JAN 01, 2002
      NHTSA ID:
      #630026

      SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »

    • TSB #01157

      Date Announced:
      AUG 06, 2001
      NHTSA ID:
      #623988

      INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »

    • TSB #13154

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #619449

      SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT Read More »

    • TSB #00262

      Date Announced:
      DEC 22, 2000
      NHTSA ID:
      #616827

      SOME ELECTRIC VEHICLES (EVS) AND ELECTRIC POSTAL CHASSIS VEHICLES MAY EXHIBIT INTERMITTENT LIGHTING OF THE OIL WARNING LAMP. *TT Read More »

    • TSB #8164

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613621

      INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR Read More »

    • TSB #99234

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090131

      INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »

    • TSB #6926

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090262

      SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT Read More »

    • TSB #99162

      Date Announced:
      AUG 09, 1999
      NHTSA ID:
      #607654

      SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0125 STORED IN MEMORY, AND / OR LACK OF HEAT WITH THE CLIMATE CONTROL. *TT Read More »

    • TSB #991210

      Date Announced:
      JUN 14, 1999
      NHTSA ID:
      #606461

      FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT Read More »

    • TSB #99111

      Date Announced:
      JUN 14, 1999
      NHTSA ID:
      #606433

      INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT Read More »

    • TSB #98259

      Date Announced:
      DEC 21, 1998
      NHTSA ID:
      #603647

      SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »

    Browse Other Ranger Years

    Become a Fan & Spread the Word