Print this page

TSB List for the 2000 Ford Ranger

Technical Service Bulletins (TSBs) for the 2000 Ranger are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.

  • STEERING
  • STEERING:HYDRAULIC POWER ASSIST SYSTEM
  • SUSPENSION
  • SUSPENSION:FRONT
  • SUSPENSION:REAR
  • SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
  • SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT
  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
  • SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
  • SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
  • SERVICE BRAKES, AIR
  • ENGINE AND ENGINE COOLING
  • ENGINE AND ENGINE COOLING:ENGINE
  • ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
  • ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
  • ENGINE AND ENGINE COOLING:COOLING SYSTEM
  • ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
  • FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
  • FUEL SYSTEM, OTHER
  • POWER TRAIN
  • POWER TRAIN:CLUTCH ASSEMBLY
  • POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
  • POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING
  • POWER TRAIN:MANUAL TRANSMISSION
  • POWER TRAIN:AUTOMATIC TRANSMISSION
  • POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
  • POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
  • POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
  • POWER TRAIN:DRIVELINE:DRIVESHAFT
  • POWER TRAIN:AXLE ASSEMBLY
  • POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING
  • POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL
  • ELECTRICAL SYSTEM
  • ELECTRICAL SYSTEM:12V/24V/48V BATTERY
  • ELECTRICAL SYSTEM:WIRING
  • ELECTRICAL SYSTEM:IGNITION:SWITCH
  • ELECTRICAL SYSTEM:IGNITION:MODULE
  • ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
  • EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
  • VISIBILITY:WINDSHIELD
  • VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
  • VISIBILITY:REARVIEW MIRRORS/DEVICES
  • VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
  • VISIBILITY:WINDSHIELD WIPER/WASHER
  • VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
  • SEAT BELTS:FRONT:RETRACTOR
  • SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
  • STRUCTURE
  • STRUCTURE:BODY
  • STRUCTURE:BODY:BUMPERS
  • STRUCTURE:BODY:DOOR
  • VEHICLE SPEED CONTROL
  • VEHICLE SPEED CONTROL:CRUISE CONTROL
  • TIRES
  • INTERIOR LIGHTING
  • EQUIPMENT
  • EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
  • EQUIPMENT:OTHER:LABELS
  • EQUIPMENT:APPLIANCE:AIR CONDITIONER
  • UNKNOWN OR OTHER
  • STEERING

    • TSB #17254

      Date Announced:
      OCT 01, 2003
      NHTSA ID:
      #10004908

      CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT Read More »

    • TSB #16040

      Date Announced:
      JUL 01, 2002
      NHTSA ID:
      #636235

      EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT Read More »

    • TSB #14289

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #620502

      SOME VEHICLES MAY EXHIBIT A STEERING CLEAR VISION CONDITION (STEERING OFF-CENTER WITH VEHICLE DRIVING STRAIGHT). *TT Read More »

    STEERING:HYDRAULIC POWER ASSIST SYSTEM

    • TSB #13440

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610879

      EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT Read More »

    SUSPENSION

    • TSB #15692

      Date Announced:
      MAR 01, 2002
      NHTSA ID:
      #636326

      SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT Read More »

    • TSB #13426

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609691

      EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT Read More »

    SUSPENSION:FRONT

    • TSB #042419

      Date Announced:
      DEC 13, 2004
      NHTSA ID:
      #10014096

      REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT Read More »

    SUSPENSION:REAR

    • TSB #15097

      Date Announced:
      JUL 01, 2001
      NHTSA ID:
      #621022

      SUBJECT REGARDING REAR ALIGNMENT OUT OF SPEC CONDITION. *TT Read More »

    • TSB #99221

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #6089679

      SOME VEHICLES MAY APPEAR TO BE LOW IN THE REAR. *TT Read More »

    • TSB #13207

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090577

      INFORMATION REGARDING REAR END SAG. *MJS Read More »

    • TSB #7026

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090410

      INFORMATION REGARDING REAR END SAG. *MJS Read More »

    SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

    SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT

    • TSB #02176

      Date Announced:
      SEP 02, 2002
      NHTSA ID:
      #10008580

      LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »

    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

    • TSB #15147

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #624885

      SOME VEHICLES MAY EXHIBIT A BRAKE PEDAL VIBRATION AND/OR STEERING WHEEL MOVEMENT,NOISE,OR BRAKE GRAB/LOCKUP . *ET Read More »

    • TSB #14898

      Date Announced:
      MAY 01, 2001
      NHTSA ID:
      #620215

      SOME VEHCLES MAY EXHIBIT A BRAKE PEDAL VIBRATION AND / OR STEERING WHEEL MOVEMENT DURING LIGHT TO MODERATE BRAKING. *TT Read More »

    • TSB #99194

      Date Announced:
      SEP 20, 1999
      NHTSA ID:
      #6090082

      INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »

    SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

    • TSB #15859

      Date Announced:
      MAY 01, 2002
      NHTSA ID:
      #637710

      SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT Read More »

    SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

    • TSB #15022

      Date Announced:
      JUN 01, 2001
      NHTSA ID:
      #622841

      CONCERNS THAT THE ANTI-LOCK BRAKE SYSTEM (ABS) LAMP IS ON WITH DIAGNOSTIC TROUBLE CODES C1230, C1229, OR C1237. *TT Read More »

    SERVICE BRAKES, AIR

    • TSB #13853

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #620276

      SOME VEHICLES EQUIPPED WITH A 4.0L OHV ENGINE MAY EXHIBIT CLOGGED / PLUGGED FUEL INJECTORS. *TT Read More »

    ENGINE AND ENGINE COOLING

    • TSB #052212

      Date Announced:
      NOV 14, 2005
      NHTSA ID:
      #10018746

      BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM - NO DTC - 3.0L 2V GAS AND FFV ENGINE. *TT Read More »

    ENGINE AND ENGINE COOLING:ENGINE

    • TSB #0415

      Date Announced:
      JAN 26, 2004
      NHTSA ID:
      #10007358

      LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE. DIAGNOSTIC SERVICE TIPS. *TT Read More »

    • TSB #0335

      Date Announced:
      FEB 17, 2003
      NHTSA ID:
      #10002482

      IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT Read More »

    • TSB #02221

      Date Announced:
      NOV 11, 2002
      NHTSA ID:
      #10008304

      ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ Read More »

    • TSB #870197

      Date Announced:
      OCT 22, 2002
      NHTSA ID:
      #10000592

      INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »

    • TSB #8504

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613656

      SOME VEHICLES EQUIPPED WITH 3.0L FLEX FUEL ENGINES MAY EXPERIENCE A HARD START / NO START CONDITION. **MR Read More »

    • TSB #00B34

      Date Announced:
      FEB 04, 2000
      NHTSA ID:
      #610228

      SOME VEHICLES WITH 3.0L 2V VULCAN ENGINES MAY BE EQUIPPED WITH A CAMSHAFT THAT WAS INCORRECTLY HEAT TREATED DURING THE MANUFACTURING PROCESS. Read More »

    • TSB #13181

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090540

      INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART (CONTINUED). *MJS Read More »

    • TSB #6997

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090310

      SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT Read More »

    • TSB #13180

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090538

      INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS Read More »

    ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

    • TSB #16100

      Date Announced:
      AUG 01, 2002
      NHTSA ID:
      #636118

      SOME VEHICLES EQUIPPED WITH A 3.0L GASOLINE ENGINE MAY EXHIBIT AN ENGINE QUIT UPON INITIAL STARTING OF THE ENGINE WITH A NORMAL RESTART AND RUN ON THE SUBSEQUENT ATTEMPT. *TT Read More »

    • TSB #01246

      Date Announced:
      DEC 10, 2001
      NHTSA ID:
      #630515

      ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT Read More »

    • TSB #15455

      Date Announced:
      DEC 01, 2001
      NHTSA ID:
      #630562

      SOME VEHICLES EQUIPPED WITH A 2.5/3.0L ENGINE MAY EXHIBIT A SURGE, HESITATION, ROUGH IDLE OR MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES P0171, P0174, P0175. *TT Read More »

    • TSB #01205

      Date Announced:
      OCT 15, 2001
      NHTSA ID:
      #627927

      SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »

    • TSB #01197

      Date Announced:
      OCT 01, 2001
      NHTSA ID:
      #627752

      SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT Read More »

    • TSB #15226

      Date Announced:
      SEP 01, 2001
      NHTSA ID:
      #625775

      SOME VEHICLES EQUIPPED WITH A 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE THAT MAY BE PERCEIVED BY THE CUSTOMER A S ADIESEL TYPE NOISE AND IS KNOWN AS MARBLE NOISE. *TT Read More »

    • TSB #15190

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #625018

      SOME VEHICLES MAY EXHIBIT SURGE, HESITATION, ROUGH IDLE OR MALFUNCTION NDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODES P0171, P0172, NP0174, P0175. *ET Read More »

    • TSB #14801

      Date Announced:
      APR 01, 2001
      NHTSA ID:
      #619306

      SOME 2000 VEHICLES MAY EXHIBIT A STALL OR IDLE DIP (BELOW 450 RPM) DURING DECELERATION OR WHILE TURNING THAT WILL ONLY OCCUR WITH A FUEL TANK LEVEL OF 3/4 OR GREATER. *TT Read More »

    • TSB #14822

      Date Announced:
      APR 01, 2001
      NHTSA ID:
      #619316

      SOME SUPERCAB 4X4 EQUIPPED VEHICLES WITH 3.0 / 4.0L ENGINES MAY EXHIBIT A LOW FREQUENCY THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. Read More »

    • TSB #0147

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619424

      SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT Read More »

    • TSB #14584

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617878

      SUBJECT REGARDING FLEX FUEL VECHICLE OIL AND FUEL RECOMMENDATIONS. *JB Read More »

    • TSB #00248

      Date Announced:
      NOV 27, 2000
      NHTSA ID:
      #616536

      SOME VEHICLES EQUIPPED WITH A 3.0L ENGINE MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *TT Read More »

    • TSB #14366

      Date Announced:
      SEP 01, 2000
      NHTSA ID:
      #618637

      SOME VEHICLES EQUIPPED WITH 3.0L ENGINE MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *JB Read More »

    • TSB #0073

      Date Announced:
      APR 03, 2000
      NHTSA ID:
      #613568

      SOME VEHICLES EQUIPPED WITH A 3.0L ENGINE MAY EXPERIENCE SPARK KNOCK (PING) UNDER ACCELERATION. **MR Read More »

    • TSB #8481

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613645

      SOME VEHCILES MAY EXHIBIT HESITATION, SURGE, ,MIL AND OR ANY CONDITION WHEN A MASS AIR FLOW (MAF) NEEDS SERVICE. **MR Read More »

    • TSB #14076

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613711

      SOME VEHICLES MAY EXHIBIT AN ENGINE SPARK KNOCK (PING) ON ACCELERATION. **MR Read More »

    • TSB #14038

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613731

      SOME VEHICLES MAY EXHIBIT HESITATION, SURGE, MALFUNCTION INDICATOR LAMP AND/OR ANY CONDITION WHEN MASS AIR FLOW (MAF) NEEDS SERVICE. **MR Read More »

    • TSB #14366

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #620429

      EXHIBITING SPARK KNOCK (PING) UNDER ACCELERATION. *TT Read More »

    • TSB #13484

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610897

      VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT Read More »

    • TSB #13528

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610914

      SOME VEHICLES WITH 3.0L ENGINES MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *TT Read More »

    • TSB #7471

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610836

      SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT Read More »

    • TSB #6896

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608921

      SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT Read More »

    • TSB #13118

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091931

      SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT Read More »

    • TSB #13154

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091965

      SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT Read More »

    ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

    • TSB #13844

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612439

      SOME VEHICLES WITH 2.5L ENGINE MAY EXHIBIT A BELT SQUEAL INITIALLY AT COLD START-UP. *TT Read More »

    • TSB #8091

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612288

      SOME VEHICLES EQUIPPED WITH 2.5L ENGINES MAY EXHIBIT A BELT SQUEAL INITIALLY AT COLD START-UP. *TT Read More »

    ENGINE AND ENGINE COOLING:COOLING SYSTEM

    • TSB #99238

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090164

      A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT Read More »

    ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

    • TSB #14583

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617968

      CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB Read More »

    • TSB #14617

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617995

      SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

    • TSB #0194

      Date Announced:
      MAY 14, 2001
      NHTSA ID:
      #620157

      SOME VEHICLES MAY EXHIBIT A STALL OR IDLE DIP (BELOW 450 RPM) DURING DECELERATION OR WHILE TURNING THAT WILL ONLY OCCUR WITH A FUEL TANK LEVEL OF 3/4 OR GREATER. Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

    • TSB #CSP-08B01

      Date Announced:
      MAY 16, 2008
      NHTSA ID:
      #10026389

      FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »

    FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

    • TSB #13853

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #620276

      SOME VEHICLES EQUIPPED WITH A 4.0L OHV ENGINE MAY EXHIBIT CLOGGED / PLUGGED FUEL INJECTORS. *TT Read More »

    • TSB #8097

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612298

      SOME VEHICLES EQUIPPED WITH A 4.0L OHV ENGINE MAY EXHIBIT CLOGGED / PLUGGED FUEL INJECTORS. *TT Read More »

    • TSB #13853

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612449

      4.0L OHV ENGINE EQUIPPED VEHICLES MAY EXHIBIT CLOGGED / PLUGGED FUEL INJECTORS. *TT Read More »

    FUEL SYSTEM, OTHER

    • TSB #0398

      Date Announced:
      MAY 12, 2003
      NHTSA ID:
      #10002780

      MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT Read More »

    POWER TRAIN

    • TSB #0332

      Date Announced:
      FEB 17, 2003
      NHTSA ID:
      #10002479

      THUMP TYPE NOISE/VIBRATION HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT Read More »

    • TSB #15887

      Date Announced:
      MAY 01, 2002
      NHTSA ID:
      #637755

      SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). Read More »

    • TSB #0282

      Date Announced:
      APR 29, 2002
      NHTSA ID:
      #637922

      SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. Read More »

    • TSB #0036

      Date Announced:
      FEB 07, 2000
      NHTSA ID:
      #612387

      VEHICLES MAY EXPERIENCE BUZZING AND OR GRINDING NOISE DURING 2-3 SHIFT- VEHICLES EQUIPPED WITH M50D TRANSMISSION AND BUILT BEFORE 11/1/99. *MJS Read More »

    • TSB #8045

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612251

      ON SOME VEHICLES THE SPEEDOMETER AND / OR ODOMETER MAY CONTINUE TO OPERATE WHILE IN KEY ON / ENGINE OFF OR KEY ON / ENGINE ON MODE WHILE THE VEHICLE IS AT A STAND STILL. *TT Read More »

    • TSB #13794

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612815

      VEHICLES EQUIPPED WITH M5OD R1 TRANSMISSIONS MAT EXHIBIT A 2-3 UPSHIFT GRIND. *MJS Read More »

    • TSB #13819

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612833

      ON SOME VEHICLES, THE SPEEDOMETER AND/OR ODOMETER MAY CONTINUE TO OPERATE WHILE IN KEY ON/ENGINE OFF OR KEY ON/ENGINE ON MODE WHILE THE VEHICLE IS AT A STAND STILL. *MJS Read More »

    • TSB #7885

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612270

      THE VEHICLE MAY EXHIBIT THE SPEEDOMETER/ODOMETER INOPERATIVE AS WELL AS MALFUNCTION INDICATOR LAMPS ILLUMINATED OR FLASHING AFTER THE GENERIC ELECTRONIC MODULE (GEM), CENTRAL TIMER MODULE (CTM), OR FOR WHEEL ANTI-LOCK BRAKE SYSTEM (4WABS) ... Read More »

    • TSB #13745

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612742

      SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS Read More »

    POWER TRAIN:CLUTCH ASSEMBLY

    • TSB #0057

      Date Announced:
      MAR 06, 2000
      NHTSA ID:
      #612953

      SOME VEHICLES MAY EXPERIENCE A SQUAWKING/EEKING NOISE THAT MAY BE HEARD FROM THE CLUTCH ON ACCELERATION FROM A STOP OR WHEN UNDER LOAD IN FIRST GEAR. *MJS Read More »

    • TSB #13442

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610880

      VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT Read More »

    • TSB #13289

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609610

      OWNERS OF VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT Read More »

    • TSB #7206

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6090799

      VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT Read More »

    • TSB #6991

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090299

      VEHICLES EQUIPPED WITH 4.0L OHV AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT Read More »

    • TSB #13175

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090528

      INFORMATION REGARDING CLUTCH SQUAWK NOISE ON TAKE OFF. *MJS Read More »

    POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

    • TSB #0255

      Date Announced:
      MAR 18, 2002
      NHTSA ID:
      #636047

      HOOTING, EEKING OR MOANING NOISE COMING FROM THE CLUTCH WHEN SHIFTING GEARS. *TT Read More »

    POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING

    • TSB #8560

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613676

      SOME VEHICLES MAY EXHIBIT AN OIL LEAK AT THE REAR SEAL OF THE TRANSMISSION EXTENSION HOUSING. **MR Read More »

    • TSB #14072

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613719

      SOME VEHICLES MAY EXHIBIT AN OIL LEAK AT THE REAR SEAL OF THE TRANSMISSION EXTENSION HOUSING. *TT Read More »

    POWER TRAIN:MANUAL TRANSMISSION

    • TSB #02138

      Date Announced:
      NOV 10, 2003
      NHTSA ID:
      #635998

      LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. Read More »

    • TSB #13835

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612428

      SOME 3.0L MANUAL TRANSMISSION EQUIPPED VEHICLES MAY EXHIBIT A CONCERN OF ENGINE IDLE HIGH (1500-2000 RPM) DURING DECELERATION. *TT Read More »

    • TSB #7366

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610793

      SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). Read More »

    • TSB #13423

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609688

      VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL AND CLUTCH ENGAGED. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION

    • TSB #0015

      Date Announced:
      JAN 10, 2000
      NHTSA ID:
      #612203

      INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »

    • TSB #8008

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612506

      BUZZING AND GRINDING NOTCHY NOISE WHEN SHIFTING(2-3 UPSHIFT). Read More »

    • TSB #7353

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610785

      SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »

    • TSB #13412

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609668

      SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT Read More »

    • TSB #99814

      Date Announced:
      MAY 03, 1999
      NHTSA ID:
      #606418

      SUBJECT REGARDING SERVICE PROCEDURE FOR 4R44E / 5R55E ORANGE SERVICE TAGGED TRANSMISSIONS. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

    • TSB #042107

      Date Announced:
      DEC 13, 2004
      NHTSA ID:
      #10014086

      GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »

    • TSB #04217

      Date Announced:
      NOV 01, 2004
      NHTSA ID:
      #10013369

      GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »

    • TSB #00216

      Date Announced:
      OCT 16, 2000
      NHTSA ID:
      #618549

      SOME VEHICLES MAY EXHIBIT A DELAYED OR SLIPPING 1-2 UPSHIFT DURING LIGHT THROTTLE. *JB Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

    • TSB #03148

      Date Announced:
      JUL 21, 2003
      NHTSA ID:
      #10003748

      NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »

    • TSB #002310

      Date Announced:
      NOV 13, 2000
      NHTSA ID:
      #616522

      SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

    POWER TRAIN:DRIVELINE:DRIVESHAFT

    • TSB #04237

      Date Announced:
      NOV 29, 2004
      NHTSA ID:
      #10013414

      DRIVESHAFT THUMP CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP. *EH Read More »

    • TSB #030302

      Date Announced:
      FEB 01, 2003
      NHTSA ID:
      #10002516

      DRIVESHAFT - THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT Read More »

    • TSB #03048

      Date Announced:
      JAN 05, 2003
      NHTSA ID:
      #10008280

      THUMP/CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP ON CERTAIN 4X4 SUPER CAB EQUIPPED WITH AUTOMATIC TRANSMISSION AND STEEL DRIVESHAFT. *TT Read More »

    • TSB #02192

      Date Announced:
      SEP 30, 2002
      NHTSA ID:
      #10008587

      DRIVESHAFT-THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. Read More »

    • TSB #011111

      Date Announced:
      JUN 11, 2001
      NHTSA ID:
      #622656

      SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY DRIVESHAFT THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. Read More »

    • TSB #0196

      Date Announced:
      MAY 14, 2001
      NHTSA ID:
      #620159

      SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. *TT Read More »

    • TSB #7886

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612273

      THE VEHICLE EQUIPPED WITH A3.0L AND AUTOMATIC/MANUAL TRANSMISSION MAY VIBRATE AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEALS TO LEAK OR THE TRANSMISSION EXTENSION HOUSING ABUISHING TO SPIN. Read More »

    POWER TRAIN:AXLE ASSEMBLY

    • TSB #030508

      Date Announced:
      APR 01, 2005
      NHTSA ID:
      #10017891

      FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT Read More »

    • TSB #0358

      Date Announced:
      MAR 17, 2003
      NHTSA ID:
      #10001922

      FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB Read More »

    • TSB #0242

      Date Announced:
      MAR 04, 2002
      NHTSA ID:
      #636056

      CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT Read More »

    • TSB #01114

      Date Announced:
      JUN 11, 2001
      NHTSA ID:
      #622642

      SOME 4X4 VEHICLES MAY EXHIBIT A HIGH-PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT AXLE AREA OF THE VEHICLE AT SPEEDS FROM 16 TO 64 KM/H (10 TO 40 MPH). *TT Read More »

    • TSB #0186

      Date Announced:
      APR 30, 2001
      NHTSA ID:
      #619276

      ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT Read More »

    • TSB #14847

      Date Announced:
      APR 01, 2001
      NHTSA ID:
      #619330

      CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT Read More »

    • TSB #01411

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619427

      HIGH-PITCHED FRONT AXLE SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT OF THE VEHICLE AT SPEEDS FROM 16 TO 64 KM/H (10 TO 40 MPH). *TT Read More »

    POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING

    • TSB #00242

      Date Announced:
      NOV 27, 2000
      NHTSA ID:
      #616530

      ON SOME VEHICLES THERE MAY BE A VIBRATION AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEAL TO LEAK OR THE TRANSMISSION EXTENSION HOUSING BUSHING TO MOVE OUT OF POSITION OR BECOME DAMAGED. Read More »

    • TSB #00151

      Date Announced:
      JUL 24, 2000
      NHTSA ID:
      #618574

      VEHICLES MAY EXPERIENCE VIBRATION FELT AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEAL TO LEAK OR THE TRANSMISSION EXTENSION HOUSING BLUSHING TO MOVE OUT OF POSITION OR BECOME DAMAGED ON SOME VEHICLES. Read More »

    • TSB #13543

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610921

      SOME VEHICLES EQUIPPED WITH 3.0L ENGINE AND AUTOMATIC / MANUAL TRANSMISSION MAY EXHIBIT TRANSMISSION FLUID LEAKAGE FROM THE TRANSMISSION EXTENSION HOUSING. *TT Read More »

    POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

    • TSB #8512

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613657

      SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR Read More »

    • TSB #14056

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613704

      SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR Read More »

    ELECTRICAL SYSTEM

    • TSB #04174

      Date Announced:
      SEP 06, 2004
      NHTSA ID:
      #10013116

      MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »

    • TSB #03203

      Date Announced:
      OCT 13, 2003
      NHTSA ID:
      #10004886

      MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »

    • TSB #03181

      Date Announced:
      SEP 15, 2003
      NHTSA ID:
      #10004027

      REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »

    • TSB #01109

      Date Announced:
      MAY 28, 2001
      NHTSA ID:
      #620165

      SOME ELECTRIC VEHICLE (EV) RANGERS MAY EXHIBIT A NO-CHARGE CONDITION. THERE ARE SEVERAL POSSIBLE CAUSES WHY THE BATTERY CONTROL MODULE (BCM) MIGHT NOT ALLOW CHARGING (AS INDICATED BY THE OP_STATES). Read More »

    • TSB #0152

      Date Announced:
      MAR 19, 2001
      NHTSA ID:
      #619431

      SOME VEHICLES MAY EXHIBIT A ROUGH IDLE, ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LAMP ILLUMINATION, INOPERATIVE OR ERRATIC SPEEDOMETER, DIAGNOSTIC TROUBLE CODES (DTCS) P0500, P0501, P0503, P1721, P0176, P1000, ABS DTC 9, RABS DTC 16, OR A ... Read More »

    • TSB #00225

      Date Announced:
      OCT 30, 2000
      NHTSA ID:
      #618562

      SOME ELECTRIC VEHICLES MAY EXHIBIT A LOW SPEED SHUDDER ON LIGHT ACCELERATION. *JB Read More »

    • TSB #13357

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6092164

      INFORMATION ON RETRIEVING DIAGNOSTIC TROUBLE CODES FROM RABS MODULES. *TT Read More »

    • TSB #7255

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6090838

      INFORMATION ON RETRIEVING DIAGNOSTIC TROUBLE CODES FROM RABS MODULES. *TT Read More »

    ELECTRICAL SYSTEM:12V/24V/48V BATTERY

    • TSB #0245

      Date Announced:
      MAR 04, 2002
      NHTSA ID:
      #636065

      INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT Read More »

    • TSB #00224

      Date Announced:
      OCT 30, 2000
      NHTSA ID:
      #618561

      SOME RANGER ELECTRIC VEHICLES (EVS) MAY EXPERIENCE STEADILY DECLINING DRIVING RANGE CAUSED BY NICKEL-METAL HYDRIDE BATTERIES THAT SUFFER FROM A CONDITION WHERE, IF NOT FULLY DISCHARGED ON A REGULAR BASIS, THE BATTERY MAY LOSE MUCH OF ITS ... Read More »

    • TSB #99167

      Date Announced:
      AUG 09, 1999
      NHTSA ID:
      #607661

      INFORMATION ON POSSIBLE BATTERY OVERCHARGE WHILE USING NGS TESTER. *TT Read More »

    • TSB #99163

      Date Announced:
      AUG 09, 1999
      NHTSA ID:
      #607671

      THIS BULLETIN MENTIONS CLARIFICATION ON HOW TO OBTAIN RANGER ELECTRIC VEHICLE (EV) TRACTION BATTERY MODULES. *TT Read More »

    ELECTRICAL SYSTEM:WIRING

    • TSB #99222

      Date Announced:
      OCT 18, 1999
      NHTSA ID:
      #6089681

      SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »

    • TSB #13208

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090579

      INFORMATION REGARDING ELECTRICAL CONNECTOR FOR TRAILER TOW. *MJS Read More »

    • TSB #7027

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090412

      INFORMATION REGARDING ELECTRICAL CONNECTOR FOR TRAILER TOW. *MJS Read More »

    ELECTRICAL SYSTEM:IGNITION:SWITCH

    • TSB #012113

      Date Announced:
      OCT 29, 2001
      NHTSA ID:
      #627774

      SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »

    ELECTRICAL SYSTEM:IGNITION:MODULE

    • TSB #01193

      Date Announced:
      OCT 01, 2001
      NHTSA ID:
      #627683

      ON SOME ELECTRIC AND ELECTRIC POSTAL VEHICLES, DIAGNOSTIC TROUBLE CODE B2785 TRACTION INVERTER MODULE (TIM) MAY BE SET AND THE VEHICLE WILL ENTER A POWER LIMITED MODE OF OPERATION. *TT Read More »

    ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

    • TSB #0162

      Date Announced:
      APR 02, 2001
      NHTSA ID:
      #619266

      VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT Read More »

    EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

    • TSB #15119

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #624608

      INFORMATION REGARDING MULTIFUNCTION SWITCH PART NUMBER CLARIFICATION. *SLC Read More »

    • TSB #00B40

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613557

      INFORMATION REGARDING MULTIFUNCTION SWITCH REPLACEMENT. **MR Read More »

    VISIBILITY:WINDSHIELD

    • TSB #13244

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090641

      INFORMATION REGARDING WINDNOISE FROM WINDSHIELD/COWL AREA. *MJS Read More »

    • TSB #13054

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091846

      EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT Read More »

    VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

    • TSB #0146

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619423

      SOME VEHICLES MAY EXHIBIT A CHATTER OR BINDING CONDITION WHEN OPERATING THE POWER SIDE WINDOWS EITHER IN THE DOWN OR UP MODE. *TT Read More »

    • TSB #996780

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608469

      THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT Read More »

    VISIBILITY:REARVIEW MIRRORS/DEVICES

    • TSB #996804

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608775

      CONCERNS WITH OUTSIDE PASSENGER OR DRIVER SIDE MIRROR SLIGHTLY FULTTERING / SHAKING AT HIGHWAY SPEEDS. *TT Read More »

    VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

    • TSB #9913072

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #609036

      VEHICLES MAY EXHIBIT AN OUTSIDE PASSENGER OR DRIVER SIDE MIRROR SLIGHT FLUTTER / SHAKE AT HIGHWAY SPEEDS. *TT Read More »

    VISIBILITY:WINDSHIELD WIPER/WASHER

    • TSB #99224

      Date Announced:
      OCT 18, 1999
      NHTSA ID:
      #6089685

      SUBJECT REGARDING FRONT WIPERS OPERATING WHILE SWITCH IS IN OFF POSITION. *TT Read More »

    VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

    • TSB #01156

      Date Announced:
      AUG 06, 2001
      NHTSA ID:
      #623944

      SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »

    SEAT BELTS:FRONT:RETRACTOR

    SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

    • TSB #0125

      Date Announced:
      FEB 05, 2001
      NHTSA ID:
      #619147

      SEAT BELT WARNING SYSTEM - BELT REMINDER FUNCTION, OPERATION AND SERVICE TIPS. *TT Read More »

    STRUCTURE

    • TSB #TSB 20-2233

      Date Announced:
      JUL 13, 2020
      NHTSA ID:
      #10177863

      This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint ... Read More »

    • TSB #TSB 19-2026

      Date Announced:
      FEB 07, 2019
      NHTSA ID:
      #10156863

      Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »

    • TSB #TSB 19-2026

      Date Announced:
      FEB 07, 2019
      NHTSA ID:
      #10155551

      Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »

    STRUCTURE:BODY

    • TSB #04251

      Date Announced:
      DEC 27, 2004
      NHTSA ID:
      #10014165

      ALUMINUM CORROSION - SERVICE TIP. *TT Read More »

    • TSB #7126

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6090720

      SOME VEHICLES MAY EXHIBIT WINDNOISE HEARD FROM THE COWL / WINDSHIELD AREA. *TT Read More »

    STRUCTURE:BODY:BUMPERS

    • TSB #02232

      Date Announced:
      NOV 25, 2002
      NHTSA ID:
      #10008311

      FRAME MOUNTED FRONT BUMPER BRACKETS SERVICE KIT. *TT Read More »

    STRUCTURE:BODY:DOOR

    • TSB #0055

      Date Announced:
      MAR 06, 2000
      NHTSA ID:
      #612949

      A CHUCKING/SUEAKING AND/OR CREAKING NOISE MAY BE HEARD FROM THE REAR DOORS WHILE DRIVING OVER BUMPS AND/OR DURING A HARD TURN WHILE STOPPING. *MJS Read More »

    • TSB #99242

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090184

      INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT Read More »

    VEHICLE SPEED CONTROL

    • TSB #14212

      Date Announced:
      JUN 01, 2000
      NHTSA ID:
      #613877

      SUBJECT REGARDING SPEED CONTROL LIGHTS OPERATIVE. *TT Read More »

    VEHICLE SPEED CONTROL:CRUISE CONTROL

    • TSB #14547

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617919

      SOME VEHICLES MAY EXHIBIT SURGE, HESITATION OR ROUGH IDLE OR MALFUNCTION INDICATOR LAMP ON W/ DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, AND P0175. *JB Read More »

    • TSB #0035

      Date Announced:
      FEB 07, 2000
      NHTSA ID:
      #612323

      VEHICLES MAY EXPERIENCE HIGH IDLE. *MJS Read More »

    TIRES

    • TSB #16510

      Date Announced:
      JAN 01, 2003
      NHTSA ID:
      #10005088

      P225/70R15 FIRESTONE WILDERNESS HT TIRE MAY EXHIBIT EXCESSIVE TIRE CUPPING/FEATHERING ON THE OUTSIDE EDGES OF THE FRONT TIRES. OASIS. *TT Read More »

    • TSB #01B77

      Date Announced:
      OCT 01, 2001
      NHTSA ID:
      #628153

      OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT Read More »

    INTERIOR LIGHTING

    • TSB #8050

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612261

      CONCERNS WITH THE INTERIOR DOME LIGHT AND / OR DOOR AJAR LIGHT REMAINING ON OR WILL GO ON / OFF INTERMITTENTLY. THIS MAY ALSO BE PRESENT WITH DRIVING OVER BUMPS AND / OR MAKING SHARP TURNS. Read More »

    • TSB #13824

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612880

      SOME VEHICLES MAY EXHIBIT THE INTERIOR DOME LIGHT AND/OR DOOR ADJAR LIGHT REMAINING ON OR WILL GO ON/OFF INTERMITTENTLY. *MJS Read More »

    EQUIPMENT

    • TSB #TSB 19-2026

      Date Announced:
      FEB 07, 2019
      NHTSA ID:
      #10156863

      Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »

    • TSB #15095

      Date Announced:
      JUL 01, 2001
      NHTSA ID:
      #621020

      INFORMATION PERTAINING TO FUEL OCTAINE PARAMETER ADJUSTMENT WITH NGS. *TT Read More »

    • TSB #01118

      Date Announced:
      JUN 11, 2001
      NHTSA ID:
      #622650

      SUBJECT REGARDING NEW VERSION 3.0 DIAGNOSTIC SOPTWARE AVAILABLE FOR CERTAIN E.V. VEHICLES. *TT Read More »

    • TSB #01412

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619428

      HIGH VOLTAGE INSULATED SAFETY GLOVES TESTING AND ORDERING INFORMATION. *TT Read More »

    • TSB #14529

      Date Announced:
      DEC 01, 2000
      NHTSA ID:
      #616838

      SUBJECT REGARDING ASH CUP NOW AVAILABLE FOR SEPARATE ORDER. *TT Read More »

    • TSB #00217

      Date Announced:
      OCT 16, 2000
      NHTSA ID:
      #618550

      SOME VEHICLES EQUIPPED WITH THE (TREMOR) PIONEER AUDIO SYSTEM MAY EXPERIENCE FRONT SPEAKERS AND / OR SUB-WOOFER SPEAKERS THAT OPERATE INTERMITTENTLY AND / OR AT A REDUCED VOLUME. *JB Read More »

    • TSB #8164

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612338

      INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT Read More »

    • TSB #6915

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090253

      SUBJECT REGARDING THE ABS MODULE ACTIVE COMMAND MODES FEATURES OF THE NGS SOFTWARE VERSION 16.1 IS NOT FUNCTIONING. *TT Read More »

    • TSB #13147

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091938

      SUBJECT REGARDING THE ABS MODULE ACTIVE COMMAND MODES FEATURE OF NGS SOFTWARE VERSION 16.1. *TT Read More »

    EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

    • TSB #14531

      Date Announced:
      DEC 01, 2000
      NHTSA ID:
      #616840

      SUBJECT REGARDING TREMOR AMPLIFIER SERVICE REPLACEMENT PROCEDURES. *TT Read More »

    • TSB #13447

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610883

      EXHIBITING A NO AUDIO OR INOPERATIVE DURING INITIAL POWER-UP. *TT Read More »

    • TSB #7423

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610812

      SSSOME VEHICLES MAY EXHIBIT A NO AUDIO OR INOPERATIVE RADIO AT INTIAL POWER-UP AFTER RADIO REPLACEMENT SERVICE. *TT Read More »

    EQUIPMENT:OTHER:LABELS

    • TSB #6694

      Date Announced:
      JUL 01, 1999
      NHTSA ID:
      #610735

      INFORMATION ON THE LOCATION OF THE OUTSIDE REAR VIEW MIRROR IMAGE LABEL. *TT Read More »

    EQUIPMENT:APPLIANCE:AIR CONDITIONER

    • TSB #01212

      Date Announced:
      OCT 29, 2001
      NHTSA ID:
      #627756

      SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A LOUD A/C CLUTCH ENGAGEMENT. *TT Read More »

    • TSB #01186

      Date Announced:
      SEP 17, 2001
      NHTSA ID:
      #625700

      INFORMATION ON CLIMATE CONTROL, LOUD A/C CLUTCH CYCLING NOISE.*JB Read More »

    • TSB #15227

      Date Announced:
      SEP 01, 2001
      NHTSA ID:
      #625777

      SOME EV VEHICLES MAY EXHIBIT A/C INOPEATIVE OR DIAGNOSTIC TROUBLE CODES RELATED TO A/C SYSTEM. *TT Read More »

    • TSB #15198

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #624982

      SOME VEHICLES MAY EXHIBIT LOUD A/C CLUTCH CYCLING NOISE CONDITION. *JG Read More »

    • TSB #15167

      Date Announced:
      AUG 01, 2001
      NHTSA ID:
      #624656

      SOME VEHICLES MAY EXHIBIT A LOUD COMPRESSOR CYCLING NOISE. *YH Read More »

    • TSB #7365

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610791

      SOME 4X4 OFF-ROAD VEHICLES BULT BETWEEN 8/10/1999 - 9/30/1999 MAY EXHIBIT A LACK OF AIR CONDITIONER COOLING PERFORMANCE. *TT Read More »

    • TSB #13422

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609687

      SOME4X4 OFF-ROAD VEHICLES BUILT BETWEEN 8/10/99 - 9/30/99 MAY EXHIBIT A LACK OF AIR CONDITIONER COOLING PERFORMANCE. *TT Read More »

    • TSB #99196

      Date Announced:
      SEP 20, 1999
      NHTSA ID:
      #6090087

      INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »

    UNKNOWN OR OTHER

    • TSB #15605

      Date Announced:
      FEB 01, 2002
      NHTSA ID:
      #630653

      SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »

    • TSB #15504

      Date Announced:
      JAN 01, 2002
      NHTSA ID:
      #630026

      SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »

    • TSB #01157

      Date Announced:
      AUG 06, 2001
      NHTSA ID:
      #623988

      INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »

    • TSB #14907

      Date Announced:
      MAY 01, 2001
      NHTSA ID:
      #620221

      CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »

    • TSB #13154

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #619449

      SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT Read More »

    • TSB #00262

      Date Announced:
      DEC 22, 2000
      NHTSA ID:
      #616827

      SOME ELECTRIC VEHICLES (EVS) AND ELECTRIC POSTAL CHASSIS VEHICLES MAY EXHIBIT INTERMITTENT LIGHTING OF THE OIL WARNING LAMP. *TT Read More »

    • TSB #14345

      Date Announced:
      SEP 01, 2000
      NHTSA ID:
      #618619

      SOME VEHICLES MAY EXHIBIT THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL STRT-UP AFTER SEVERAL HOURS OF COLD SOAK. *JB Read More »

    • TSB #8164

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613621

      INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR Read More »

    • TSB #99234

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090131

      INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »

    • TSB #6926

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090262

      SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT Read More »

    Browse Other Ranger Years

    Become a Fan & Spread the Word