Technical Service Bulletins (TSBs) for the 1996 Thunderbird are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
VEHICLES EXHIBIT A PULL WHILE BRAKING - CHECK FOR KINKED BRAKE LINES , REPLACE IF NECESSARY - REPLACE LOWER ARM AND STRUT BUSHINGS ON THE SIDE THE VEHICLE PULL TO. *TW Read More »
SOME VEHICLES MAY EXHIBIT BRAKE ROUGHNESS (BRAKE PEDAL PULSATION, STEERING WHEEL SHAKE AND / OR NIBBLE) UNDER LIGHT BRAKE APPLICATIONS FROM 105 TO 0 KM/H (65 TO 0 MPH). *YC Read More »
INFORMATION STATING THAT THE REAR BRAKES ON VEHICLES WITHOUT THE ANTI-LOCK BRAKE SYSTEM (ABS) WERE CHANGED ON 11/18/95 FROM DRUM BRAKES TO DISC BRAKES. *TT Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. Read More »
SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT Read More »
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN RPM FLARE ON A FORCED 4/2 DOWNSHIFT. ADDITIONALLY, THE COMMANDED ELECTRONIC PRESSURE CONTROL IS AT APPROMATELY 10 PSI. *TT Read More »
AIR INLET-WATER IN AIR INLET ELBOW-MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATES DUE TO WATER CONTAMINATION OF AIR FILTER AND/OR MASS AIR FLOW SENSOR (MAF)- VEHICLE SWITH 4.6L ENGINE. *AK Read More »
THERE MAY BE DELAYED ENGAGEMENTS FROM "PARK" TO "REVERSE" OR "PARK" TO "OVERDRIVE" AND/OR DELAYED 1-2 SHIFTS OR ROUGH 3-4 SHIFTS- THIS MAY BE DUE TO THE CALIBRATION OF THE POWERTRAIN CONTROL MODULE. Read More »
SOME 4R70W TRANSMISSIONS WERE BUILT WITH A UNIQUE CASE AND REQUIRE A SPACER TO BE INSTALLED BETWEEN THE LOW / REVERSE SERVO COVER AND RETAINING RING. *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION:COLUMN SHIFT ASSEMBLY
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. Read More »
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS ... Read More »
LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE. Read More »
VIBRATION- TIRES- VIBRATION FELT WHILE DRIVING AT HIGHWAY SPEEDS- VEHICLES BUILT THROUGH 12/20/96 EQUIPPED WITH 16 INCH GOODYEAR TIRES. *JD Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
VEHICLE EXHIBITS A PULL WHILE BRAKING, FOLLOW PROCEDURES OUTLINED IN 06-00-4 & PINPOINT TEST "A" ON 06-00-5 OF THE 1997 SERVICE MANUAL. *JD Read More »
