2008 GMC Yukon investigations

2008 GMC Yukon

3 Defect Investigations from the NHTSA

NHTSA Defect Investigations for the 2008 GMC Yukon

The Office of Defects Investigations (ODI) is an office within the NHTSA which investigates serious safety problems in the design, construction or performance of vehicles. The NHTSA is authorized to order manufacturers to recall and repair vehicles, if the ODI finds a safety issue. NHTSA investigations for the 2008 GMC Yukon, both ongoing and closed, are listed below:

  1. NON-CRASH ENGINE COMPARTMENT FIRES NHTSA Preliminary Evaluation #PE08010

    • Status:
      CLOSED
    • Date Opened: February 04, 2008
    • Date Closed: June 12, 2008
    • Recall: no recall issued

    Component(s): Electrical System
    Electrical System:Battery
    Electrical System:Battery:Cables
    Electrical System:Wiring
    Electrical System:Wiring:Front Underhood
    Engine And Engine Cooling
    Engine And Engine Cooling:Engine

    Summary: In response to an information request letter sent by the Office Of Defects Investigation(ODI) during preliminary evaluation PE08-010, GM provided ODI with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.ODI has also received 5 reports, 4 of which are of duplicative of reports provided by GM, alleging non-crash engine compartment fires in the subject vehicles.in total, ODI is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (EA08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles.

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #PE08010 »

  2. NON-CRASH ENGINE COMPARTMENT FIRES NHTSA Engineering Analysis #EA08010

    Component(s): Electrical System
    Electrical System:Battery
    Electrical System:Fuses And Circuit Breakers
    Electrical System:Wiring
    Electrical System:Wiring:Front Underhood
    Engine And Engine Cooling
    Engine And Engine Cooling:Engine
    Visibility:Windshield Wiper/Washer
    Visibility:Windshield Wiper/Washer:Switch/Wiring

    Summary: In a letter dated August 27, 2008, General Motors Corp. (GM) notified NHTSA that it will conduct a safety recall (NHTSA recall number 08V-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. According to GM, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. This may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, GM dealers will install a wire harness with an in-line fuse. In addition to the subject vehicles, several other GM models with the heated windshield washer fluid option are included in recall 08V-441: MY 2006-2008 Buick lucerne (manufactured August 2005 through November 2007); MY 2008 Buick enclave (manufactured February 2007 through April 2007); MY 2006-2008 Cadillac dts (manufactured May 2007 through November 2007); MY 2007-2008 Saturn outlook (manufactured August 2006 through April 2007); and MY 2007-2008 GMC acadia (manufactured August 2006 through April 2007) vehicles.GM is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. GM's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed.

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #EA08010 »

  3. Interior Door Handle Laceration Risk NHTSA Preliminary Evaluation #PE09044

    • Status:
      CLOSED
    • Date Opened: September 14, 2009
    • Date Closed: May 23, 2010
    • Recall: no recall issued

    Component(s): Latches/Locks/Linkages:Doors:Latch
    Structure:Body:Door

    Summary: The statistical data regarding problem experience in the table above are net counts for unique vehicles.Review of information in this PE discloses that while accounting for approximately two-thirds of the total population, MY 2007 subject vehicles are cited in more than 90 percent of the consumer complaints, injury reports, and warranty claims, respectively.In addition, improvements in the door handle manufacturing process during the MY 2007 production resulted in a decline in the occurrence of peeling/flaking of the thin chrome plating.Other environmental factors were also identified that may have influenced the occurrence of the condition which poses the alleged safety risk.Additional analysis is required to identify the specific vehicles most susceptible to peeling or separation of the chrome plating from the handle, and to assess the significance of its occurrence.This PE has been upgraded to an Engineering Analysis to facilitate further study.

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #PE09044 »

Browse Other Yukon Years

Become a Fan & Spread the Word