NHTSA Defect Investigations for the 2006 Dodge Durango

The Office of Defects Investigations (ODI) is an office within the NHTSA which investigates serious safety problems in the design, construction or performance of vehicles. The NHTSA is authorized to order manufacturers to recall and repair vehicles, if the ODI finds a safety issue. NHTSA investigations for the 2006 Dodge Durango, both ongoing and closed, are listed below:

  1. Air Bag Inflator Rupture NHTSA Engineering Analysis #EA15001

    • Status:
      OPEN
    • Date Opened: February 24, 2015
    • Date Closed: Pending
    • Recall: possible recall

    Component(s): Air Bags
    Air Bags:Frontal

    Summary: The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at ODI's insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, areas with high absolute humidity and climatic conditions believed to be a significant factor in the inflator ruptures.As part of the recall actions, inflators removed from remedied vehicles are to be returned to Takata for testing.Takata's initial test results on passenger inflators from remedied vehicles indicated a much higher than anticipated rupture frequency for inflators returned from Florida.Accordingly ODI requested all 10 manufacturers expand the regional recalls for passenger inflators to include other geographic areas where high absolute humidity conditions exist, including the Gulf States and other coastal areas.Takata's testing of the passenger inflators to date continues to indicate this geographic area as having the highest risk, with no ruptures occurring from inflators returned from outside the expanded recall regions.During PE14-016 four additional passenger inflator field events occurred, all in vehicles from the same expanded geographic region.Also during PE14-016 four additional driver inflator field events occurred including two in vehicles from regions not known for high absolute humidity, specifically California and North Carolina.Accordingly, ODI requested all five of the affected vehicle manufacturers currently using the subject Takata driver inflators expand to nationwide recalls.Significantly, neither of the affected vehicle manufacturers or Takata provided any explanation to account for these two driver air bag inflator ruptures outside the area of high absolute humidity.Takata testing of returned driver inflators indicates a lower rupture frequency as compared to passenger inflator testing.All test ruptures reported by Takata to date have occurred on inflators returned from high absolute humidity areas.The investigation now includes all manufacturers and vehicles known to be affected at this time.ODI's investigation will focus on, among other things, root cause analysis, other potential defect consequences, identification of affected vehicles scope, and adequacy of the remedy.The five ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10537899, 10568848, 10585224, 10605877, 10651492

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #EA15001 »

  2. Air Bag Inflator Rupture NHTSA Preliminary Evaluation #PE14016

    Component(s): Air Bags
    Air Bags:Frontal

    Summary: The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at ODI's insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, areas with consistently high absolute humidity and climatic conditions believed to be a significant factor in the inflator ruptures.As part of the recall actions, inflators removed from remedied vehicles are to be returned to Takata for testing.Takata's initial test results on passenger inflators from remedied vehicles indicated a much higher than anticipated rupture frequency for inflators returned from Florida.Accordingly, ODI requested all 10 manufacturers expand the regional recalls for passenger inflators to include other geographic areas where high absolute humidity conditions exist, including the Gulf States and other coastal areas.Takata's testing of the passenger inflators to date continues to indicate this geographic area as having the highest risk, with no ruptures occurring from inflators returned from outside the expanded recall regions.During PE14-016, four additional passenger inflator field events occurred, all in vehicles from the same expanded geographic region.Also during PE14-016, four additional driver inflator field events occurred including two in vehicles from regions not known for high absolute humidity, specifically California and North Carolina.Accordingly, ODI requested all five of the affected vehicle manufacturers currently using the subject Takata driver inflators expand to nationwide recalls.Significantly, neither of the affected vehicle manufacturers or Takata provided any explanation to account for these two driver air bag inflator ruptures outside the area of high absolute humidity.Takata testing of returned driver inflators indicates a lower rupture frequency as compared to passenger inflator testing.All test ruptures reported by Takata to date have occurred on inflators returned from high absolute humidity areas.The PE is now closed/upgraded to an Engineering Evaluation (EA15-001) to include all manufacturersand vehicles known to be affected at this time.ODI's EA investigation will focus on, among other things, root cause analysis, other potential defect consequences, identification of affected vehicles scope, and adequacy of the remedy.The recalls related to this PE are: 14V343, 14V344, 14V348, 14V351, 14V353, 14V655, 14V700, 14V701, 14V752, 14V763, 14V770, 14V773, 14V787, 14V802 and 14V817.The number of vehicles affected are an estimate since some vehicles may have both the driver and passenger side inflators recalled. The five ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10537899, 10568848, 10585224, 10605877, 10651492

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #PE14016 »

  3. SIDE CURTAIN AIR BAG FAILURE NHTSA Engineering Analysis #EA07003

    • Status:
      CLOSED
    • Date Opened: February 14, 2007
    • Date Closed: February 08, 2008
    • Recall: no recall issued

    Component(s): Air Bags:Side/Window

    Summary: ODI's investigation identified no issues in the design, manufacturing process, or quality control process of the side curtain air bags used in the Dodge Durango vehicles.there have been no reported field incidents of side curtain air bag failures similar to the failures that occurred during the NHTSA research testing of the Durango air bags.additional NHTSA testing conducted during this investigation resulted in no diffuser tube failures.a safety-related defect has not been identified at this time and further use of Agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.the Agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.see document file for additional information.

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #EA07003 »

  4. SIDE CURTAIN AIR BAG FAILURE NHTSA Preliminary Evaluation #PE06045

    • Status:
      CLOSED
    • Date Opened: October 19, 2006
    • Date Closed: February 14, 2007
    • Recall: no recall issued

    Component(s): Air Bags:Side/Window

    Summary: ODI has upgraded this investigation to an engineering analysis (EA07-003) to continue its investigation of the subject issue.

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #PE06045 »

  5. STEERING WHEEL AND STEERING SHAFT BOLTS NHTSA Engineering Analysis #EA06004

    • Status:
      CLOSED
    • Date Opened: March 09, 2006
    • Date Closed: March 08, 2007
    • Recall: no recall issued

    Component(s): Steering
    Steering:Column

    Summary: On March 9, 2006 ODI upgraded preliminatry evaluation PE05-056 to engineerning analysis EA06-004 to investigate allegations of loose or missing steering shaft coupling bolts and steering column retaining bolts in model year (MY) 2004 through 2006 Dodge Durango sport utility vehicles and MY 2005 through 2006 Dodge Dakota pickup trucks.either condition could result in a loss of steering control.although ODI identified some quality issues in the manufacturing processes for the Dakota and Durango vehicles, the data do not indicate that a safety defect trend is present in either population.the failure rates are low for each condition and trend analyses indicate that problems with the subject bolts were isolated to a few units affected by assembly error that were detected either pre-sale or occurred early in vehicle service.further use of Agency resources in this matter does not appear to be warranted.the Agency will continue to monitor complaints and other information relating to the alleged defect in the sugject vehicles and will take furhter action inthe the future if warranted.for more information see the attached closing report.

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #EA06004 »

  6. Fleet Vehicle Recall Completion Audit NHTSA Defect Investigation #AQ10001

    • Status:
      CLOSED
    • Date Opened: November 18, 2010
    • Date Closed: December 28, 2015
    • Recall: no recall issued

    Component(s): Unknown Or Other

    Summary: On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ""Associated Documents" link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.

    NHTSA: For detailed information & supporting documents, see the official NHTSA page concerning investigation #AQ10001 »

Browse Other Durango Years